Please wait a minute...
金属学报  2013, Vol. 49 Issue (2): 207-213    DOI: 10.3724/SP.J.1037.2012.00357
  论文 本期目录 | 过刊浏览 |
HCO3-, SO42-和Cl-混合体系中Cu点蚀行为的研究
王长罡,董俊华,柯伟,李晓芳
中国科学院金属研究所金属腐蚀与防护国家重点实验室, 沈阳 110016
INVESTIGATION ON PITTING CORROSION BEHAVIOR OF COPPER IN THE MIXED SOLUTION OF HCO3-, SO42- AND Cl-
WANG Changgang, DONG Junhua, KE Wei, LI Xiaofang
State Key Laboratory for Corrosion and Protection, Institute of Metal Research, Chinese Academy of Sciences, Shenyang 110016
引用本文:

王长罡,董俊华,柯伟,李晓芳. HCO3-, SO42-和Cl-混合体系中Cu点蚀行为的研究[J]. 金属学报, 2013, 49(2): 207-213.
WANG Changgang, DONG Junhua, KE Wei, LI Xiaofang. INVESTIGATION ON PITTING CORROSION BEHAVIOR OF COPPER IN THE MIXED SOLUTION OF HCO3-, SO42- AND Cl-[J]. Acta Metall Sin, 2013, 49(2): 207-213.

全文: PDF(1470 KB)  
摘要: 

HCO3-浓度为0.08 mol/L及不同浓度配比的SO42-和Cl-混合溶液中, 利用循环极化电化学测试方法和SEM, 对Cu工作电极的循环极化行为和点蚀表面形貌进行了系统的研究. 结果表明, SO42-或Cl-均能促进Cu的阳极溶解, 且二者间存在交互作用. Cl-能降低Cu电极的腐蚀电位, 增强其电化学活性. 在点蚀敏感区域图中, Cu发生点蚀的临界Cl-浓度为0.02 mol/L. 当Cl-浓度较低时, SO42-对点蚀敏感性无影响; 当Cl-浓度为中等时, SO42-抑制点蚀; 当Cl-浓度较高时, SO42-使Cu点蚀敏感性先升高后降低. 无论SO42-浓度的高低, Cl-都能促进点蚀. 在本研究体系中, Cu的点蚀敏感性强烈地受到Cl-和SO42-的影响.

关键词 高放废物地质处置Cu点蚀, HCO3- SO42-Cl-    
Abstract

In this work, the pitting corrosion behavior of Cu in the mixed solution of HCO3-, Cl- and SO42- simulating groundwater was investigated by means of cyclic polarization test and SEM microscopy. The results showed that both SO42- and Cl- can synergistically promote the anodic dissolution of Cu electrode. Cl- can decrease the corrosion potential of Cu to enhance its electrochemical activity. The plot of pitting sensitivity of Cu showed that the pitting critical concentration of Cl- was 0.02 mol/L. When the concentration of Cl- was low, SO42- did not affect the pitting susceptibility; when the concentration of Cl- was in the middle, SO42- strongly inhibited the pitting corrosion of Cu; when the concentration of Cl- was high, the pitting susceptibility will first increase and then reduce with increasing the concentration of SO42-. Regardless of what concentration of SO42-, Cl- can promote the pitting corrosion of Cu. In the current solution system, it is found that the pitting corrosion of Cu was sorely sensitive to SO42- and Cl-.

Key wordshigh-level radioactive waste    copper    pitting    HCO3-, SO42-    Cl-
收稿日期: 2012-06-15     
基金资助:

国家自然科学基金资助项目51071160

作者简介: 王长罡, 男, 1985年生, 博士

[1] Wang C G, Dong J H, Ke W, Chen N. Acta Metall Sin, 2011; 47: 354


(王长罡, 董俊华, 柯伟, 陈楠. 金属学报, 2011; 47: 354)

[2] Lytle D A, Nadagouda M N. Corros Sci, 2010; 52: 1927

[3] Baba H, Kodama T, Fujii T. Trans Natl Res Inst Met, 1986; 2: 248

[4] Christy A G, Lowe A, Otieno--Alego V, Stoll M, Webster R D. J Appl Electrochem, 2004; 34: 225

[5] Edwards M, Ferguson J F, Reiber S H. J Am Water Works Association, 1994; 86(7): 74

[6] Sosa M, Patel S, Edwards M. Corrosion, 1999; 55: 1069

[7] Edwards M, Rehring J, Mayer T. Corrosion, 1994; 50: 366

[8] Drogowska M, Brossard L, Menard H. J Electrochem Soc, 1992; 139: 39

[9] Duthil J P, Mankowski G, Giusti A. Corros Sci, 1996; 38: 1839

[10] Cong H, Scully J R. J Electrochem Soc, 2010; 157: C200

[11] Nishikata A, Itagaki M, Tsuru T, Haruyama S. Corros Sci, 1990; 31: 287

[12] Jujii T. Trans Natl Res Inst Met, 1988; 30: 81

[13] Drogowska M, Brossard L, Menard H. J Electrochem Soc, 1992; 139: 39

[14] Guo Y H, Wang J, Wang Z M, Liu S F, Su R. Bull Mineral Petrol Geochm, 2007; (26): 607

(郭永海, 王驹, 王志明, 刘淑芬, 苏锐. 矿物岩石地球化学通报, 2007; (26): 607)

[15] Fujii T, Kodama T, Baba H. Corros Sci, 1984; 24: 901

[16] Drogowska M, Brossard L, Menard H. Surf Coat Technol, 1988; 34: 383

[17] Reda M R, Alhajji J N. Corrosion, 1996; 52: 232

[18] Cantor A F, Park J K, Vaiyavatjamai P. J Am Water Works Assoc, 2003; 95(5): 112

[19] Wang C G, Dong J H, Ke W, Chen N. Acta Metall Sin, 2012; 48: 85

(王长罡, 董俊华, 柯伟, 陈楠. 金属学报, 2012; 48: 85)

[20] Wang C G, Dong J H, Ke W, Chen N. Acta Metall Sin, 2012; 48: 1365

(王长罡, 董俊华, 柯伟, 陈楠. 金属学报, 2012; 48: 1365)

[21] Abd El Meguid E A, Awad N K. Corros Sci, 2009; 51: 1134

 
[1] 王宗谱, 王卫国, Rohrer Gregory S, 陈松, 洪丽华, 林燕, 冯小铮, 任帅, 周邦新. 不同温度轧制Al-Zn-Mg-Cu合金再结晶后的{111}/{111}近奇异晶界[J]. 金属学报, 2023, 59(7): 947-960.
[2] 陈润农, 李昭东, 曹燕光, 张启富, 李晓刚. 9%Cr合金钢在含Cl环境中的初期腐蚀行为及局部腐蚀起源[J]. 金属学报, 2023, 59(7): 926-938.
[3] 吴东江, 刘德华, 张子傲, 张逸伦, 牛方勇, 马广义. 电弧增材制造2024铝合金的微观组织与力学性能[J]. 金属学报, 2023, 59(6): 767-776.
[4] 刘满平, 薛周磊, 彭振, 陈昱林, 丁立鹏, 贾志宏. 后时效对超细晶6061铝合金微观结构与力学性能的影响[J]. 金属学报, 2023, 59(5): 657-667.
[5] 王寒玉, 李彩, 赵璨, 曾涛, 王祖敏, 黄远. 基于纳米活性结构的不互溶W-Cu体系直接合金化及其热力学机制[J]. 金属学报, 2023, 59(5): 679-692.
[6] 万涛, 程钊, 卢磊. 组元占比对层状纳米孪晶Cu力学行为的影响[J]. 金属学报, 2023, 59(4): 567-576.
[7] 许林杰, 刘徽, 任玲, 杨柯. CuNi-Ti合金抗支架内再狭窄与耐蚀性能的影响[J]. 金属学报, 2023, 59(4): 577-584.
[8] 巩向鹏, 伍翠兰, 罗世芳, 沈若涵, 鄢俊. 自然时效对Al-2.95Cu-1.55Li-0.57Mg-0.18Zr合金160℃人工时效的影响[J]. 金属学报, 2023, 59(11): 1428-1438.
[9] 冯迪, 朱田, 臧千昊, 李胤樹, 范曦, 张豪. 喷射成形过共晶AlSiCuMg合金的固溶行为[J]. 金属学报, 2022, 58(9): 1129-1140.
[10] 韩冬, 张炎杰, 李小武. 短程有序对高层错能Cu-Mn合金拉-拉疲劳变形行为及损伤机制的影响[J]. 金属学报, 2022, 58(9): 1208-1220.
[11] 刘续希, 柳文波, 李博岩, 贺新福, 杨朝曦, 恽迪. 辐照条件下Fe-Cu合金中富Cu析出相的临界形核尺寸和最小能量路径的弦方法计算[J]. 金属学报, 2022, 58(7): 943-955.
[12] 朱小绘, 刘向兵, 王润中, 李远飞, 刘文庆. 290℃氩离子辐照对Fe-Cu合金微观组织的影响[J]. 金属学报, 2022, 58(7): 905-910.
[13] 吴彩虹, 冯迪, 臧千昊, 范诗春, 张豪, 李胤樹. 喷射成形AlSiCuMg合金的热变形组织演变及再结晶行为[J]. 金属学报, 2022, 58(7): 932-942.
[14] 袁波, 郭明星, 韩少杰, 张济山, 庄林忠. 添加3%ZnAl-Mg-Si-Cu合金非等温时效析出行为的影响[J]. 金属学报, 2022, 58(3): 345-354.
[15] 唐帅, 蓝慧芳, 段磊, 金剑锋, 李建平, 刘振宇, 王国栋. 铁素体区等温过程中Ti-Mo-Cu微合金钢中的共析出行为[J]. 金属学报, 2022, 58(3): 355-364.