Please wait a minute...
金属学报  2013, Vol. 49 Issue (2): 251-256    DOI: 10.3724/SP.J.1037.2012.00557
  论文 本期目录 | 过刊浏览 |
稀土镁合金微细电火花加工变质层微观结构及性能研究
孙术发1, 2),狄士春1),吕鹏翔1),韦东波1),喻杰1),郭豫鹏1)
1) 哈尔滨工业大学机电工程学院, 哈尔滨 150001
2) 东北林业大学工程技术学院, 哈尔滨 150040
MICROSTRUCTURE AND PROPERTIES OF METAMORPHIC LAYER FORMED ON Mg-RE ALLOY IN MICRO-EDM PROCESS
SUN Shufa 1, 2), DI Shichun 1), LU Pengxiang 1), WEI Dongbo 1),YU Jie 1), GUO Yupeng 1)
1) School of Mechatronics Engineering, Harbin Institute of Technology, Harbin 15000
12) Institute of Engineering and Technology, Northeast Forestry University, Harbin 150040
引用本文:

孙术发,狄士春,吕鹏翔,韦东波,喻杰,郭豫鹏. 稀土镁合金微细电火花加工变质层微观结构及性能研究[J]. 金属学报, 2013, 49(2): 251-256.
SUN Shufa, DI Shichun, LU Pengxiang, WEI Dongbo, YU Jie, GUO Yupeng. MICROSTRUCTURE AND PROPERTIES OF METAMORPHIC LAYER FORMED ON Mg-RE ALLOY IN MICRO-EDM PROCESS[J]. Acta Metall Sin, 2013, 49(2): 251-256.

全文: PDF(3393 KB)  
摘要: 

利用微细电火花不同工艺加工了稀土镁合金. 采用SEM和XPS分析了加工后稀土镁合金表面变质层形貌和成分, 采用纳米压痕仪分析了变质层的硬度, 采用动电位极化曲线评价了变质层的耐腐蚀性能. 结果表明, 变质层表面有微裂纹, 降低加工电压和电流可以减少微裂纹, 增大脉宽和脉间可以有效消除微裂纹; 在3种不同介质中加工得到的变质层表面均发生了氧化反应, 在去离子水中加工的变质层表面还发生了显著的电化学腐蚀; 变质层的硬度高于稀土镁合金基体, 其最高硬度可达到1.664 GPa; 动电位极化曲线表明, 变质层可以改善稀土镁合金的耐腐蚀性能.

关键词 稀土镁合金微细电火花变质层硬度腐蚀    
Abstract

In this work, the Mg-RE alloy metamorphic layer was formed in the micro-EDM process in different process parameters. The morphology and composition of the metamorphic layer were detected by SEM and XPS, the hardness of the metamorphic layer was measured by a nanoindentor, the corrosion resistance property was investigated by using a potentiodynamic polarization test. The results show that there are microcracks on the surface of metamorphic layer, the microcracks can be reduced by decreasing processing voltage and current, and it can be further eliminated by increasing pulse wide and pulse interval. The oxidation caused on the surface of metamorphic layers in the micro-EDM process in three different dielectrics among which there was significantly electrochemical corrosion on the surface in deionized water. The hardness of metamorphic layer is enhanced compared to the substrate of Mg-RE alloy, and its maximum value is about 1.664 GPa. The potentiodynamic polarization test shows that the corrosion resistance of the Mg-RE alloy was improved significantly due to the existence of the metamorphic layer.

Key wordsMg-RE alloy    micro-EDM    metamorphic layer    hardness, corrosion
收稿日期: 2012-09-21     
基金资助:

国家高技术研究发展计划资助项目2009AA044205

作者简介: 孙术发, 男, 1980年生, 博士生

[1] Yao H B, Li Y, Wee A T S. Electrochim Acta, 2003; 48: 4197


[2] Chen H B, Yang B. Int J Min Met Mater, 2009; 16: 672

[3] Wang X B, Tian X B, Gong C Z, Yang S Q. J Inorg Mater, 2011; 26: 711

(王晓波, 田修波, 巩春志, 杨士勤. 无机材料学报, 2011; 26: 711)

[4] Ding W J, Zeng X Q. Acta Metall Sin, 2010; 46: 1450

(丁文江, 曾小勤. 金属学报, 2010; 46: 1450)

[5] Li H Z, Liu H T, Li F B, Wang H J, Liang X P, Liu C M. J Mater Eng Perform, 2012; 21: 1056

[6] Chang J W, Guo X W, He S M, Fu P H, Peng L M, Ding W J. Corros Sci, 2008; 50: 166

[7] Chang J W, Duo J, Xiang Y Z, Yang H Y, Ding W J, Peng Y H. Int J Min Met Mater, 2011; 18: 203

[8] Peng L M, Chang J W, Guo X W, Atrens A, Ding W J, Peng Y H. J Appl Electrochem, 2009; 39: 913

[9] Xu N J, Liu C S, Shang S, Wang Z Y. J Northeastern Univ (Nat Sci), 2012; 33: 1133

(许妮君, 刘常升, 商硕, 王政一. 东北大学学报(自然科学版), 2012; 33: 1133)

[10] Guckel H, Fischer K, Stiers E, Chaudhuri B, McNamara S, Ramotowski M, Johnson E D, Kirk C. Microsyst Technol, 1999; 6: 103

[11] Liu J C, Bai J C, Guo Y F. Non-Traditional Machining Technology.5th Ed., Beijing: China Machine Press, 2010: 7

(刘晋春, 白基成, 郭永丰. 特种加工. 第5版. 北京:机械工业出版社, 2010: 7)

[12] Osenbruggen C V. Philips Technish Tijdschrift, 1969; 20: 200

[13] Joo C P, Kim B H, Choi D K, Chu C N. J Mech Sci Technol, 2008; 22: 300

[14] Ghanem F, Braham C, Sidhom H. J Mater Process Technol, 2003; 142: 163

[15] Cho D H, Lee S A, Lee Y Z. Tribology Lett, 2012; 45: 123

[16] Ma G R, Xu Z J. Electromachining, 1984; 3: 5

(马光荣, 徐祯基. 电加工, 1984; 3: 5)

[17] Zhao W S. Advanced EDM Machining Technology. Beijing: National Defence Industry Press, 2003: 34

(赵万生. 先进电火花加工技术. 北京: 国防工业出版社, 2003: 34)

[18] Jahan M P, Wong Y S, Rahman M. J Mater Process Technol, 2009; 209: 1706

 [19] Bouvier Y, Mutel B, Grimblot J. Surf Coat Technol, 2004; 18: 169

 [20] Kumar S, Singh R, Singh T P, Sethi B L. J Mater Process Technol, 2009; 209: 3675

 [21] Harcuba P, Bacakova L, Strasky J, Bacakova M, Novotna K, Janecek M. J Mech Behav Biomed Mater, 2012; 7: 96

 
[1] 张奇亮, 王玉超, 李光达, 李先军, 黄一, 徐云泽. EH36钢在不同粒径沙砾冲击下的冲刷腐蚀耦合损伤行为[J]. 金属学报, 2023, 59(7): 893-904.
[2] 赵平平, 宋影伟, 董凯辉, 韩恩厚. 不同离子对TC4钛合金电化学腐蚀行为的协同作用机制[J]. 金属学报, 2023, 59(7): 939-946.
[3] 李小涵, 曹公望, 郭明晓, 彭云超, 马凯军, 王振尧. 低碳钢Q235、管线钢L415和压力容器钢16MnNi在湛江高湿高辐照海洋工业大气环境下的初期腐蚀行为[J]. 金属学报, 2023, 59(7): 884-892.
[4] 陈润农, 李昭东, 曹燕光, 张启富, 李晓刚. 9%Cr合金钢在含Cl环境中的初期腐蚀行为及局部腐蚀起源[J]. 金属学报, 2023, 59(7): 926-938.
[5] 王宗谱, 王卫国, Rohrer Gregory S, 陈松, 洪丽华, 林燕, 冯小铮, 任帅, 周邦新. 不同温度轧制Al-Zn-Mg-Cu合金再结晶后的{111}/{111}近奇异晶界[J]. 金属学报, 2023, 59(7): 947-960.
[6] 司永礼, 薛金涛, 王幸福, 梁驹华, 史子木, 韩福生. Cr添加对孪生诱发塑性钢腐蚀行为的影响[J]. 金属学报, 2023, 59(7): 905-914.
[7] 吴欣强, 戎利建, 谭季波, 陈胜虎, 胡小锋, 张洋鹏, 张兹瑜. Pb-Bi腐蚀Si增强型铁素体/马氏体钢和奥氏体不锈钢的研究进展[J]. 金属学报, 2023, 59(4): 502-512.
[8] 韩恩厚, 王俭秋. 表面状态对核电关键材料腐蚀和应力腐蚀的影响[J]. 金属学报, 2023, 59(4): 513-522.
[9] 王京阳, 孙鲁超, 罗颐秀, 田志林, 任孝旻, 张洁. 以抗CMAS腐蚀为目标的稀土硅酸盐环境障涂层高熵化设计与性能提升[J]. 金属学报, 2023, 59(4): 523-536.
[10] 常立涛. 压水堆主回路高温水中奥氏体不锈钢加工表面的腐蚀与应力腐蚀裂纹萌生:研究进展及展望[J]. 金属学报, 2023, 59(2): 191-204.
[11] 廖京京, 张伟, 张君松, 吴军, 杨忠波, 彭倩, 邱绍宇. Zr-Sn-Nb-Fe-V合金在过热蒸汽中的周期性钝化-转折行为[J]. 金属学报, 2023, 59(2): 289-296.
[12] 夏大海, 计元元, 毛英畅, 邓成满, 祝钰, 胡文彬. 2024铝合金在模拟动态海水/大气界面环境中的局部腐蚀机制[J]. 金属学报, 2023, 59(2): 297-308.
[13] 胡文滨, 张晓雯, 宋龙飞, 廖伯凯, 万闪, 康磊, 郭兴蓬. 共晶高熵合金AlCoCrFeNi2.1H2SO4 溶液中的腐蚀行为[J]. 金属学报, 2023, 59(12): 1644-1654.
[14] 宋嘉良, 江紫雪, 易盼, 陈俊航, 李曌亮, 骆鸿, 董超芳, 肖葵. 高铁转向架用钢G390NH在模拟海洋和工业大气环境下的腐蚀行为及产物演化规律[J]. 金属学报, 2023, 59(11): 1487-1498.
[15] 王海峰, 张志明, 牛云松, 杨延格, 董志宏, 朱圣龙, 于良民, 王福会. 前置渗氧对TC4钛合金低温等离子复合渗层微观结构和耐磨损性能的影响[J]. 金属学报, 2023, 59(10): 1355-1364.