|
|
两相区位错增殖对Mn元素配分及低碳钢贝氏体组织的影响 |
陈连生1, 李跃1, 张明山1, 田亚强1( ), 郑小平1, 徐勇1,2, 张士宏2 |
1 华北理工大学教育部现代冶金技术重点实验室 唐山 063210 2 中国科学院金属研究所 沈阳 110016 |
|
Effect of Intercritical Dislocation Multiplication to Mn Partitioning and Microstructure Evolution of Bainite in Low Carbon Steel |
Liansheng CHEN1, Yue LI1, Mingshan ZHANG1, Yaqiang TIAN1( ), Xiaoping ZHENG1, Yong XU1,2, Shihong ZHANG2 |
1 Key Laboratory of the Ministry of Education for Modern Metallurgy Technology, North China University of Science and Technology, Tangshan 063210, China 2 Institute of Metal Research, Chinese Academy of Sciences, Shenyang 110016, China |
引用本文:
陈连生, 李跃, 张明山, 田亚强, 郑小平, 徐勇, 张士宏. 两相区位错增殖对Mn元素配分及低碳钢贝氏体组织的影响[J]. 金属学报, 2017, 53(11): 1418-1426.
Liansheng CHEN,
Yue LI,
Mingshan ZHANG,
Yaqiang TIAN,
Xiaoping ZHENG,
Yong XU,
Shihong ZHANG.
Effect of Intercritical Dislocation Multiplication to Mn Partitioning and Microstructure Evolution of Bainite in Low Carbon Steel[J]. Acta Metall Sin, 2017, 53(11): 1418-1426.
[1] | Lis J, Lis A, Kolan C.Manganese partitioning in low carbon manganese steel during annealing[J]. Mater. Charact., 2008, 59: 1021 | [2] | Khaira H K, Jena A K, Chaturvedi M C.Effects of heat treatment cycle on equilibrium between ferrite and austenite during intercritical annealing[J]. Mater. Sci. Eng., 1993, A161: 267 | [3] | Coates D E.Diffusion controlled precipitate growth in ternary systems: II[J]. Matall. Trans., 1973, 4: 1077 | [4] | Coates D E.Diffusion-controlled precipitate growth in ternary systems: I[J]. Matall. Trans., 1972, 3: 1203 | [5] | Hillert M.Nature of local equilibrium at the interface in the growth of ferrite from alloyed austenite[J]. Scr. Mater., 2002, 46: 447 | [6] | Hoel R H.Metallography and partitioning of alloying elements in dual-phase steels[J]. Metallography, 1984, 17: 273 | [7] | Tian Y Q, Zhang H J, Chen L S, et al.Effect of alloy elements partitioning behavior on retained austenite and mechanical property in low carbon high strength steel[J]. Acta Metall. Sin., 2014, 50: 531(田亚强, 张宏军, 陈连生等. 低碳高强钢合金元素配分行为对残余奥氏体和力学性能的影响[J]. 金属学报, 2014, 50: 531) | [8] | Yabuuchi K, Kasada R, Kimura A.Effect of Mn addition on one-dimensional migration of dislocation loops in body-centered cubic Fe[J]. Acta Mater., 2013, 61: 6517 | [9] | Sampath S, Rementeria R, Huang X, et al.The role of silicon, vacancies, and strain in carbon distribution in low temperature bainite[J]. J. Alloys Compd., 2016, 673: 289 | [10] | Hu B F, Kinoshita H, Takahashi H.Irradiation damage and radiation induced segregation at grain boundaries of the welding heat affected zone in Fe-Cr-Mn (W, V) alloy[J]. Acta Metall. Sin., 1999, 10: 1090(胡本芙, 木下博嗣, 高桥平七郎. Fe-Cr-Mn(W, V)合金焊接热影响区的辐照损伤及诱发的晶界元素偏析[J]. 金属学报, 1999, 10: 1090) | [11] | Fischer F D, Svoboda J.Substitutional diffusion in multicomponent solids with non-ideal sources and sinks for vacancies[J]. Acta Mater., 2010, 58: 2698. | [12] | Chen L S, Zhang J Y, Tian Y Q, et al.Effect of Mn pre-partitioning on C partitioning and retained austenite of Q&P steels[J]. Acta Metall. Sin., 2015, 51: 527(陈连生, 张健杨, 田亚强等. 预先Mn配分处理对Q&P钢中C配分及残余奥氏体的影响[J]. 金属学报, 2015, 51: 527) | [13] | Liu H P, Sun H E, Liu B, et al.An ultrahigh strength steel with ultrafine-grained microstructure produced through intercritical deformation and partitioning process[J]. Mater. Des., 2015, 83: 760 | [14] | Hu Z P, Xu Y B, Tan X D.Intercritical austenite stabilization of a Mn-Al TRIP steel[J]. J. Northeast. Univ.(Nat. Sci.), 2016, 37: 179(胡智评, 许云波, 谭小东. 一种Mn-Al系TRIP钢的临界区奥氏体稳定化研究[J]. 东北大学学报(自然科学版), 2016, 37: 179) | [15] | Zhu S S, Wang Z Z, Mao X Y, et al.A review about strengthening-toughening technologies for ferrite-pearlite non-quenched and tempered steels[J]. Mater. Rev., 2016, 30(9): 122(朱帅帅, 王章忠, 毛向阳等. 铁素体-珠光体型非调质钢强韧化技术研究进展[J]. 材料导报, 2016, 30(9): 122) | [16] | Browning N D, Chisholm M F, Pennycook S J.Atomic-resolution chemical analysis using a scanning transmission electron microscope[J]. Nature, 1993, 366: 143 | [17] | Williams D B, Carter C B.Transmission Electron Microscopy: A Textbook for Materials Science [M]. New York: Plenum Press, 1996: 1 | [18] | Kostka A, Tak K G, Hellmig R J, et al.On the contribution of carbides and micrograin boundaries to the creep strength of tempered martensite ferritic steels[J]. Acta Mater., 2007, 55: 539 | [19] | Aghajani A.Evolution of microstructure during long-term creep of a tempered martensite ferritic steel [D]. Bochum: Ruhr-University Bochum, 2009 | [20] | Pe?i?ka J, Ku?el R, Dronhofer A, et al.The evolution of dislocation density during heat treatment and creep of tempered martensite ferritic steels[J]. Acta Mater., 2003, 51: 4847 | [21] | Zhang S H, He X L, Chu Y Y, et al.Behavior of vacancy influence during diffusion in metals[J]. Acta Metall. Sin., 1992, 28(5): A187(章三红, 贺信莱, 褚幼义等. 扩散过程中空位的作用及其地位[J]. 金属学报, 1992, 28(5): A187) | [22] | Xu S, Guo Y F.Generation and evolution of vacancy-type defects in nano-Cu films during plastic deformation by means molecular dynamics[J]. Acta Phys. Sin., 2013, 62: 196201(徐爽, 郭雅芳. 纳米铜薄膜塑性变形中空位型缺陷形核与演化的分子动力学研究[J]. 物理学报, 2013, 62: 196201) | [23] | Chen L S, Zhang J Y, Tian Y Q, et al.Study on morphology feature and mechanism in transformation process of austenite during intercritical annealing of low-carbon steel[J]. Hot Working Technol., 2015, 44(16): 223(陈连生, 张健杨, 田亚强等. 低碳钢双相区奥氏体组织特征及形成机理研究[J]. 热加工工艺, 2015, 44(16): 223) | [24] | Luo H W, Shi J, Wang C, et al.Experimental and numerical analysis on formation of stable austenite during the intercritical annealing of 5Mn steel[J]. Acta Mater., 2011, 59: 4002 | [25] | Sun S J, Pugh M.Manganese partitioning in dual-phase steel during annealing[J]. Mater. Sci. Eng., 2000, A276: 167 | [26] | Hu G X, Cai X, Rong Y H.Fundamentals of Materials Science [M]. Shanghai: Shanghai Jiao Tong University Press, 2000: 1(胡赓祥, 蔡珣, 戎咏华. 材料科学基础 [M]. 上海: 上海交通大学出版社, 2000: 1) | [27] | Speer J G, Matlock D K.Recent developments in low-carbon sheet steels[J]. JOM, 2002, 54(7): 19 | [28] | Li Y J, Li X L, Yuan G, et al.Microstructure and partitioning behavior characteristics in low carbon steels treated by hot-rolling direct quenching and dynamical partitioning processes[J]. Mater. Charact., 2016, 121: 157 |
|
|
Viewed |
|
|
|
Full text
|
|
|
|
|
Abstract
|
|
|
|
|
Cited |
|
|
|
|
|
Shared |
|
|
|
|
|
Discussed |
|
|
|
|