|
|
Effect of Gravity on Directionally Solidified Structure of Superalloys |
MA Dexin1,2( ), ZHAO Yunxing1,2, XU Weitai1, WANG Fu3 |
1Shenzhen Wedge Central South Research Institute Co. Ltd., Shenzhen 518045, China 2Powder Metallurgy Research Institute, Central South University, Changsha 410083, China 3School of Mechanical and Electrical Engineering, Xi'an Jiaotong University, Xi'an 710049, China |
|
Cite this article:
MA Dexin, ZHAO Yunxing, XU Weitai, WANG Fu. Effect of Gravity on Directionally Solidified Structure of Superalloys. Acta Metall Sin, 2023, 59(9): 1279-1290.
|
Abstract While using traditional methods of directionally solidifying superalloy castings, the liquid density at the lower region of the mushy zone gradually lowers than the top. This is due to a strong segregation of alloying elements. The gravitational force then exacerbates this density inversion, leading to upward convection from the mushy zone to the liquid ahead of the solidification front. This process, known as solutal convection, results in several solidification defects such as freckle defects, an upward accumulation of γ/γ' eutectic, and seeding process issues. As higher-generation single crystal superalloys continue to develop, the problems of element segregation and solutal convection become more pronounced. Traditional measures, such as adjusting process parameters, struggle to effectively alleviate these issues. Given that these problems largely arise from gravity-induced fluid flow, this work aims to investigate the role of gravity on solidification structure and propose appropriate solutions. To achieve this, the conventional pull-down and novel pull-up methods were adopted to perform directional solidification experiments with superalloys. The influence of gravity on solidification behavior is starkly different in these two experiments. In the pull-down process, dendrites grow upward, against gravity, leading to a variety of solidification defects such as freckles on the casting's lateral surface and an upward accumulation of γ/γ' eutectic on the upper surface of the single crystal turbine blade castings. Stray grains also formed in the remelting region during seeding. These phenomena are caused by the density inversion of the remaining liquid between dendrites, resulting in a top-heavy and bottom-light hydrodynamic state. Liquid convection in the mushy zone was then unavoidable under gravity in the pull-down process. In contrast, the pull-up process had dendrites growing downwards, in line with gravity, leaving the least dense liquid at the top of the mushy zone. In this top-light and bottom-heavy state, gravity stabilizes the segregated residual liquid in the mushy zone, thereby preventing solutal convection. Consequently, freckle defects were eliminated, and the γ/γ' eutectic structure was evenly distributed, not accumulated, on the upper surface of the single crystal blade's platform. Additionally, the stability of remelting and epitaxial growth of seed crystals was ensured by eliminating liquid convection. By using this pull-up process, the negative effects of gravity on the directional solidification of superalloys were removed, and all gravity-related solidification defects consequently disappeared. This novel pull-up process could potentially be developed into a new production process for single crystal superalloy castings, significantly improving casting quality. However, it should be noted that this new pull-up process is more complex in comparison to the conventional method. Although this work lays the groundwork for this process, further technological enhancements are required before this method can be applied to industrial production.
|
Received: 31 March 2023
|
|
Fund: Guangdong Innovative and Entrepreneurial Research Team Program(607264877417);Shenzhen Peacock Plan(KQTD2015032716463668) |
1 |
Giamei A F, Kear B H. On the nature of freckles in nickel base superalloys [J]. Metall. Trans., 1970, 1: 2185
doi: 10.1007/BF02643434
|
2 |
Copley S M, Giamei A F, Johnson S M, et al. The origin of freckles in unidirectionally solidified castings [J]. Metall. Trans., 1970, 1: 2193
doi: 10.1007/BF02643435
|
3 |
Auburtin P, Wang T, Cockcroft S L, et al. Freckle formation and freckle criterion in superalloy casting [J]. Metall. Mater. Trans., 2000, 31B: 801
|
4 |
Tin S, Pollock T M. Predicting freckle formation in single crystal Ni-base superalloys [J]. J. Mater. Sci., 2004, 39: 7199
doi: 10.1023/B:JMSC.0000048732.02111.ee
|
5 |
Ma D X, Wu Q, Bührig-Polaczek A. Some new observations on freckle formation in directionally solidified superalloy components [J]. Metall. Mater. Trans., 2012, 43B: 344
|
6 |
Ma D X, Bührig-Polaczek A. The geometrical effect on freckle formation in the directionally solidified superalloy CMSX-4 [J]. Metall. Mater. Trans., 2014, 45A: 1435
|
7 |
Ma D X. Freckle formation during directional solidification of complex castings of superalloys [J]. Acta Metall. Sin., 2016, 52: 426
|
|
马德新. 定向凝固的复杂形状高温合金铸件中的雀斑形成 [J]. 金属学报, 2016, 52: 426
doi: 10.11900/0412.1961.2015.00379
|
8 |
Ma D X, Dong Z H, Wang F, et al. A phenomenological analysis of freckling in directional solidification of Ni-base superalloy: The role of edge and curvature in casting components [J]. Metall. Mater. Trans., 2020, 51A: 88
|
9 |
Seo S M, Lee J H, Yoo Y S, et al. A comparative study of the γ/γ' eutectic evolution during the solidification of Ni-base superalloys [J]. Metall. Mater. Trans., 2011, 42A: 3150
|
10 |
D’Souza N, Dong H B, Ardakani M G, et al. Solidification path in the Ni-base superalloy, IN713LC——Quantitative correlation of last stage solidification [J]. Scr. Mater., 2005, 53: 729
doi: 10.1016/j.scriptamat.2005.05.012
|
11 |
Wang F, Ma D X, Zhang J, et al. Effect of solidification parameters on the microstructures of superalloy CMSX-6 formed during the downward directional solidification process [J]. J. Crystal Growth, 2014, 389: 47
doi: 10.1016/j.jcrysgro.2013.11.084
|
12 |
Wang F, Ma D X, Zhang J, et al. Effect of local cooling rates on the microstructures of single crystal CMSX-6 superalloy: A comparative assessment of the Bridgman and the downward directional solidification processes [J]. J. Alloys Compd., 2014, 616: 102
doi: 10.1016/j.jallcom.2014.07.084
|
13 |
Wang F, Ma D X, Zhang J, et al. Solidification behavior of a Ni-based single crystal CMSX-4 superalloy solidified by downward directional solidification process [J]. Mater. Charact., 2015, 101: 20
doi: 10.1016/j.matchar.2015.01.003
|
14 |
Zhu Y X, Xu L Y, Zhao H E, et al. Formation of γ + γ' eutectic and control of σ-phase in a high Al-Ti cast Ni-base superalloy [J]. Acta Metall. Sin., 1986, 22: A93
|
|
朱耀宵, 徐乐英, 赵洪恩 等. 一种铸造镍基高温合金中(γ + γ')共晶的形成及σ相的控制 [J]. 金属学报, 1986, 22: A93
|
15 |
Warnken N, Ma D X, Mathes M, et al. Investigation of eutectic island formation in SX superalloys [J]. Mater. Sci. Eng., 2005, A413-414: 267
|
16 |
D’Souza N, Dong H B. Solidification path in third-generation Ni-based superalloys, with an emphasis on last stage solidification [J]. Scr. Mater., 2007, 56: 41
doi: 10.1016/j.scriptamat.2006.08.060
|
17 |
D’Souza N, Lekstrom M, Dai H J, et al. Quantitative characterisation of last stage solidification in nickel base superalloy using enthalpy based method [J]. Mater. Sci. Technol., 2007, 23: 1085
doi: 10.1179/174328407X213224
|
18 |
Ma D X, Wang F, Weng X H, et al. Influence of MC carbides on the formation of γ/γ' eutectics in single crystal superalloy CM247LC [J]. Acta Metall. Sin., 2017, 53: 1603
|
|
马德新, 王 富, 温序晖 等. CM247LC单晶高温合金中MC碳化物对γ/γ'共晶反应的影响 [J]. 金属学报, 2017, 53: 1603
doi: 10.11900/0412.1961.2017.00110
|
19 |
Ma D X, Wang F. Randomly orientated eutectic grains in single crystal castings of superalloys [J]. Foundry, 2019, 68: 1342
|
|
马德新, 王 富. 高温合金单晶铸件中的杂乱共晶缺陷 [J]. 铸造, 2019, 68: 1342
|
20 |
Ma D X, Zhao Y X, Wei J H, et al. Upward accumulation analysis of eutectics in single crystal superalloy blade castings [J]. Foundry, 2021, 70: 1302
|
|
马德新, 赵运兴, 魏剑辉 等. 单晶高温合金叶片铸件中的共晶上聚现象分析 [J]. 铸造, 2021, 70: 1302
|
21 |
Ma D X, Zhao Y X, Xu W T, et al. Surface effect on eutectic structure distribution in single crystal superalloy castings [J]. Acta Metall. Sin., 2021, 57: 1539
doi: 10.11900/0412.1961.2020.00404
|
|
马德新, 赵运兴, 徐维台 等. 高温合金单晶铸件中共晶组织分布的表面效应 [J]. 金属学报, 2021, 57: 1539
doi: 10.11900/0412.1961.2020.00404
|
22 |
Yang X L, Ness D, Lee P D, et al. Simulation of stray grain formation during single crystal seed melt-back and initial withdrawal in the Ni-base superalloy CMSX4 [J]. Mater. Sci. Eng., 2005, A413-414: 571
|
23 |
Zhao N R, Li J G, Liu J L, et al. Solidification interface in growth of single crystal superalloys by seeding technique [J]. J. Mater. Eng., 2007, (11): 24
|
|
赵乃仁, 李金国, 刘金来 等. 籽晶法生长高温合金单晶凝固界面研究 [J]. 材料工程, 2007, (11): 24
|
24 |
Yang W C, Hu S S, Huo M, et al. Orientation controlling of Ni-based single-crystal superalloy by a novel method: Grain selection assisted by un-melted reused seed [J]. J. Mater. Res. Technol., 2019, 8: 1347
doi: 10.1016/j.jmrt.2018.10.005
|
25 |
Hu S S, Liu L, Yang W C, et al. Inhibition of stray grains at melt-back region for re-using seed to prepare Ni-based single crystal superalloys [J]. Progr. Nat. Sci. Mater. Int., 2019, 29: 582
doi: 10.1016/j.pnsc.2019.08.006
|
26 |
Ford D A, Hill A D. Single crystal seed alloy [P]. US Pat, 6740176, 2004
|
27 |
Guo J, Li J G, Liu J D, et al. Formation mechanism of fusion zone in growth of single crystal superalloy with low-segregated heterogeneous seed [J]. Acta Metall. Sin., 2018, 54: 419
doi: 10.11900/0412.1961.2017.00144
|
|
郭 静, 李金国, 刘纪德 等. 低偏析异质籽晶制备单晶高温合金的籽晶熔合区形成机制研究 [J]. 金属学报, 2018, 54: 419
|
28 |
Ma D X, Zhao Y X, Xu W T, et al. Influence of seeding materials on epitaxial growth of single crystal superalloys [J]. Chin. J. Nonferrous Met., 2023, 33: 445
|
|
马德新, 赵运兴, 徐维台 等. 高温合金籽晶材料对单晶外延生长的影响 [J]. 中国有色金属学报, 2023, 33: 445
|
29 |
Ma D X, Zhang Q Y, Wang H Y, et al. Effect of solidification condition change on stray grain defect formation in single crystal casting of superalloys [J]. Foundry, 2019, 68: 103
|
|
马德新, 张琼元, 王海洋 等. 高温合金单晶铸造中凝固条件的时空变化及对杂晶缺陷的影响 [J]. 铸造, 2019, 68: 103
|
30 |
Beckmann C, Gu J P, Boettinger W J. Development of a freckle predictor via Rayleigh number method for single-crystal nickel-base superalloy castings [J]. Metall. Mater. Trans., 2000, 31A: 2545
|
No Suggested Reading articles found! |
|
|
Viewed |
|
|
|
Full text
|
|
|
|
|
Abstract
|
|
|
|
|
Cited |
|
|
|
|
|
Shared |
|
|
|
|
|
Discussed |
|
|
|
|