Please wait a minute...
金属学报  2009, Vol. 45 Issue (7): 840-843    
  论文 本期目录 | 过刊浏览 |
相续室温蠕变中屈服强度附近的应力应变行为
聂德福;赵杰
(大连理工大学材料科学与工程学院; 大连 116024)
STRESS--STRAIN BEHAVIORS AROUND THE YIELD STRENGTH IN SEQUENTIAL ROOM TEMPERATURE CREEP TESTS
NIE Defu; ZHAO Jie
School of Materials Science and Engineering; Dalian University of Technology; Dalian 116024
引用本文:

NIE Defu ZHAO Jie. 相续室温蠕变中屈服强度附近的应力应变行为[J]. 金属学报, 2009, 45(7): 840-843.

全文: PDF(825 KB)  
摘要: 

研究了正火态X70管线钢的相续室温蠕变现象及其对随后变形的影响, 结果表明, 在屈服点上、下的数种应力水平下X70钢均存在室温蠕变现象, 且通常呈现为速率递减的α型蠕变.屈服点后的室温蠕变提高了随后的流变应力. 利用应变速率--应力曲线判断室温蠕变对随后应力应变行为的影响:经历低于屈服强度的室温蠕变过程后, 应变速率突变点明显低于普通拉伸实验的比例极限;而在较高应力水平下的室温蠕变使随后的应变速率--应力曲线出现明显峰值.利用局部可动位错密度模型解释了室温蠕变的影响.

关键词 室温蠕变屈服强度 X70管线钢应变速率    
Abstract

The deformation of metallic materials at low homologous temperature (the ratio of experimental temperature and melting point T/Tm<0.2) used to be described by time independent models. With the development of measuring technique and the improvement of required accuracy, the time dependence of deformation has been concerned about. So far, room temperature creep (RTC) has been observed in many metals and alloys, and some experiments have been performed to investigate the fundamental deformation mechanism and influencing factors. A previous paper reported that RTC increased the subsequent flow stress of an X70 pipeline steel. However, the evolution of deformation following RTC is not thoroughly understood. In this paper, sequential RTC tests and their effects on the subsequent deformation have been investigated in the X70 pipeline steel. The steel exhibits time dependent deformation at various stress levels around yield strength, and RTC is generally primary α type. Moreover, the post--yield RTC markedly enhances the subsequent flow stress. The influence of RTC on subsequence stress--strain behavior can be evaluated using strain rate--stress curve: the burst point of strain rate, due to pre--yield RTC process, is lower than elastic limit, while a distinct peak is observed after RTC has been performed at higher stress level. Local mobile dislocation model has been applied to analyze the behavior.

Key wordsroom temperature creep    yield strength    X70 pipeline steel    strain rate
收稿日期: 2008-12-01     
ZTFLH: 

TG111

 
基金资助:

国家自然科学基金资助项目50271013

作者简介: 聂德福, 男, 1979年生, 博士

[1] Zhao Z B, Northwood D O, Liu C, Liu Y X. J Mater Process Technol, 1999; 89–90: 569
[2] Neeraj T, Hou D H, Daehn G S, Mills M J. Acta Mater, 2000; 48: 1225
[3] Krempl E, Khan F. Int J Plast, 2003; 19: 1069
[4] Yamada T, Kawabata K, Sato E, Kuribayashi K, Jimbo I. Mater Sci Eng, 2004; A387: 719
[5] Oehlert A, Atrens A. Mater Forum, 1993; 17: 415
[6] Wang S H, Chen W X. Mater Sci Eng, 2001; A301: 147
[7] Nie D F, Zhao J, Mo T, Chen W X. Mater Lett, 2008; 62: 51
[8] Alden T H. Metall Trans, 1987; 18A: 51
[9] Alden T H. Metall Trans, 1987; 18A: 811

[1] 王凯, 晋玺, 焦志明, 乔珺威. CrFeNi中熵合金在宽温域拉伸条件下的力学行为与变形本构方程[J]. 金属学报, 2023, 59(2): 277-288.
[2] 常立涛. 压水堆主回路高温水中奥氏体不锈钢加工表面的腐蚀与应力腐蚀裂纹萌生:研究进展及展望[J]. 金属学报, 2023, 59(2): 191-204.
[3] 王楠, 陈永楠, 赵秦阳, 武刚, 张震, 罗金恒. 应变速率对X80管线钢铁素体/贝氏体应变分配行为的影响[J]. 金属学报, 2023, 59(10): 1299-1310.
[4] 沈国慧, 胡斌, 杨占兵, 罗海文. 回火温度对含 δ 铁素体高铝中锰钢力学性能和显微组织的影响[J]. 金属学报, 2022, 58(2): 165-174.
[5] 张聪惠, 荣花, 宋国栋, 胡坤. 喷丸表面粗糙度对纯Ti焊接接头在HCl溶液中应力腐蚀开裂行为的影响[J]. 金属学报, 2019, 55(10): 1282-1290.
[6] 马歌, 左秀荣, 洪良, 姬颖伦, 董俊媛, 王慧慧. 深海用X70管线钢焊接接头腐蚀行为研究[J]. 金属学报, 2018, 54(4): 527-536.
[7] 李旭东, 毛萍莉, 刘晏宇, 刘正, 王志, 王峰. 高应变速率下Mg-3Zn-1Y镁合金的各向异性及变形机制[J]. 金属学报, 2018, 54(4): 557-565.
[8] 李细锋, 陈楠楠, 李佼佼, 何雪婷, 刘红兵, 郑兴伟, 陈军. 温度与应变速率对Invar 36合金变形行为的影响[J]. 金属学报, 2017, 53(8): 968-974.
[9] 杨旭, 廖波, 刘坚, 严伟, 单以银, 肖福仁, 杨柯. 中国低活化马氏体钢在液态Pb-Bi中的脆化现象[J]. 金属学报, 2017, 53(5): 513-523.
[10] 赵小宇, 黄峰, 甘丽君, 胡骞, 刘静. MS X70酸性环境用管线钢焊接接头氢致开裂敏感性及氢捕获效率研究[J]. 金属学报, 2017, 53(12): 1579-1587.
[11] 蔡贇,孙朝阳,万李,阳代军,周庆军,苏泽兴. AZ80镁合金动态再结晶软化行为研究*[J]. 金属学报, 2016, 52(9): 1123-1132.
[12] 谢锐,吕铮,卢晨阳,李正元,丁学勇,刘春明. 9Cr-ODS钢中纳米析出相的SAXS和TEM研究*[J]. 金属学报, 2016, 52(9): 1053-1062.
[13] 陈瑞,许庆彦,柳百成. Al-Mg-Si合金中针棒状析出相时效析出动力学及强化模拟研究*[J]. 金属学报, 2016, 52(8): 987-999.
[14] 张可,雍岐龙,孙新军,李昭东,赵培林. 卷取温度对Ti-V-Mo复合微合金化超高强度钢组织及力学性能的影响*[J]. 金属学报, 2016, 52(5): 529-537.
[15] 顾伟,李静媛,王一德. 晶粒尺寸及Taylor因子对过时效态7050铝合金挤压型材横向力学性能的影响*[J]. 金属学报, 2016, 52(1): 51-59.