Please wait a minute...
金属学报  2010, Vol. 46 Issue (8): 951-958    DOI: 10.3724/SP.J.1037.2010.00102
  论文 本期目录 | 过刊浏览 |
外加电位对X80钢及其焊缝在库尔勒土壤 模拟溶液中SCC行为的影响
陈旭,吴明,何川,肖军
辽宁石油化工大学石油天然气工程学院, 抚顺 113001
EFFECT OF APPLIED POTENTIAL ON SCC OF X80 PIPELINE STEEL AND ITS WELD JOINT IN KU’ERLE SOIL SIMULATED SOLUTION
CHEN Xu, WU Ming, HE Chuan, XIAO Jun
College of Petroleum Engineering, Liaoning Shihua University, Fushun 113001
引用本文:

陈旭 吴明 何川 肖军. 外加电位对X80钢及其焊缝在库尔勒土壤 模拟溶液中SCC行为的影响[J]. 金属学报, 2010, 46(8): 951-958.
, , , . EFFECT OF APPLIED POTENTIAL ON SCC OF X80 PIPELINE STEEL AND ITS WELD JOINT IN KU’ERLE SOIL SIMULATED SOLUTION[J]. Acta Metall Sin, 2010, 46(8): 951-958.

全文: PDF(5627 KB)  
摘要: 

采用动电位扫描技术和慢应变速率拉伸实验研究了X80钢及其焊缝在库尔勒土壤模拟溶液中的应力腐蚀行为, 并利用扫描电镜观察了不同外加电位下的断口形貌.结果表明, X80管线钢及其焊缝在库尔勒土壤模拟溶液中的极化曲线具有典型的活性溶解特征. 阳极极化及自腐蚀电位下, 裂纹萌生于点蚀坑及夹杂物处,X80钢及其焊缝的开裂机制为阳极溶解; 外加电位为-900 mV(vs SCE)时,母材处于阴极保护状态, 应力腐蚀敏感性较低, 而焊缝的应力腐蚀敏感性明显增加; 当外加电位负移至-1200 mV(vs SCE), 母材和焊缝均表现出较高的SCC敏感性,其开裂机制为氢和应力协同作用下的氢致开裂. 相同电位下, 焊缝的应力腐蚀敏感性高于母材, 其断裂位置多在热影响区, 这是由焊接过程中产生的冶金相变和残余应力造成的.

关键词 X80管线钢 焊缝 土壤模拟溶液 外加电位 应力腐蚀开裂    
Abstract

Potentiodynamic polarization technique and slow strain rate testing (SSRT) were employed to study the stress corrosion cracking (SCC) behavior of a welded X80 pipeline steel in Ku’erle soil simulated solution. Fracture surfaces were observed by SEM under different applied potential conditions. The results show that the polarization curves of the base metal and weld joint represent the typical characteristics of active dissolution. It is found that cracks are generally initiated at corrosion pits and inclusions under anode polarization and open circuit potential. The crack generation mechanism of X80 pipeline base steel and weld metal are attributed to the dissolution at anode. When the applied potential is −900 mV (vs SCE), the base metal exhibites lower SCC sensitivity due to cathodic protection while under the same condition welded joins higher SCC sensitivity. Both the base metal and weld joins exhibite higher SCC sensitivity under −1200 mV (vs SCE) polarization potential and their cracking generation mechanism is hydrogen induced cracking (HIC) due to the synergistic action of stress and hydrognCommonly the weld joint is more sensitive to SCC than the base etal under the same applid potential, and fractures are usually presented in heat affected zone (HAZ) and this is attributed to metallurgical phase transformation and residual stress enerated during welding process.

Key wordsX80 pipeline steel    weld joint    soil simulated solution    applied potential    stress corrosion cracking
收稿日期: 2010-03-01     
基金资助:

国家自然科学基金资助项目50771053

作者简介: 陈旭, 女, 1974年生, 副教授, 博士
[1] Li J, Elboujdaini M, Gao M, Revie R W. Mater. Sci. Eng, A, 2008, 486: 496 [2] Liu Z Y, Li X G, Zhang Y R, Du C W. Acta Metall Sin (English Letters), 2009, 22: 58 [3] Li M C, Cheng Y F. Electrochimica Acta, 2007, 52: 8111 [4] Fazzini P G, Otegui J L. International Journal of Pressure Vessels and Piping, 2007, 84: 739 [5] Liu Z Y, Li X G, Du C W, Cheng Y F. Corros. Sci., 2009, 51: 2863 [6] Gamboa E, Linton V, Law M. Int. J. Fatigue, 2008, 30: 850 [7] Wang J Q, Atrens A. Corros. Sci., 2003, 45: 2199 [8] Krist K., Leewis L., Willmoff M. Pipeline & Gas Journal, 1998, 225: 49 [9] Parkins R N, Zhou S. Corr. Sci, 1997, 39: 159 [10] Parkins R N, Zhou S. Corr. Sci, 1997, 39: 175 [11] Danielson Mike J, Jones Russell H, Krist Kevin. CORROSION/2000, NACE International, Houston, TX, 2000, Paper No.359 [12] Charles E A, Parkins R N. Corrosion, 1995, 51: 518 [13] Pikey A K, Lambert S B, Plumtree A. Corrosion, 1995, 51: 91 [14 ]Wang J Q, Atrens A, Cousens D R, et al. Journal of Materials Science, 1999, 34:1711 [15] Mao X, Liu X, Revie R W. Corrosion, 1994, 50: 651 [16] :Cao C N. Corrosion of Metals in Nature Environment in China. Beijing: Chemical Industry Press, 2004: 286 (曹楚南. 中国材料的自然环境腐蚀. 北京: 化学工业出版社, 2004: 286 ) [17] Van Boven G, Chen W, Rogge R. Acta Mater, 2007, 55: 29 [18] Chu R, Chen W, Wang S H, et al. Corrosion, 2004, 60: 275 [19] Davies D H, Burstein G T. Corrosion, 1980, 36: 416 [20] Li M C, Cheng Y F. Electrochimica Acta, 2008, 53: 2831 [21] Zhang T ,Sun X L ,Chen J S ,et al. Pipeline Technique and Equipment , 2004, 2:33 (张涛,孙新岭,陈居术,等.氢在高强度管道钢应力腐蚀中的作用[J].管道技术与设备,2004, 2:33) [22] Zhang G A, Cheng Y F. Electrochimica Acta, 2009, 55: 316 [23] Zhang G A, Cheng Y F. Corr. Sci, 2009, 51: 1714
[1] 马志民, 邓运来, 刘佳, 刘胜胆, 刘洪雷. 淬火速率对7136铝合金应力腐蚀开裂敏感性的影响[J]. 金属学报, 2022, 58(9): 1118-1128.
[2] 骆文泽, 胡龙, 邓德安. SUS316不锈钢马鞍形管-管接头的残余应力数值模拟及高效计算方法开发[J]. 金属学报, 2022, 58(10): 1334-1348.
[3] 陈芳,李亚东,杨剑,唐晓,李焰. X80钢焊接接头在模拟天然气凝析液中的腐蚀行为[J]. 金属学报, 2020, 56(2): 137-147.
[4] 邓平,孙晨,彭群家,韩恩厚,柯伟,焦治杰. 核用304不锈钢辐照促进应力腐蚀开裂研究[J]. 金属学报, 2019, 55(3): 349-361.
[5] 张体明, 赵卫民, 蒋伟, 王永霖, 杨敏. X80钢焊接残余应力耦合接头组织不均匀下氢扩散的数值模拟[J]. 金属学报, 2019, 55(2): 258-266.
[6] 邵盈恺, 王玉玺, 杨志斌, 史春元. 基于焊缝熔深优化的7075铝合金等离子-MIG复合焊接热裂纹敏感性[J]. 金属学报, 2018, 54(4): 547-556.
[7] 余军, 张德平, 潘若生, 董泽华. 井下含硫环空液中P110油管钢应力腐蚀开裂的电化学噪声特征[J]. 金属学报, 2018, 54(10): 1399-1407.
[8] 苑洪钟,刘智勇,李晓刚,杜翠薇. 外加电位对X90钢及其焊缝在近中性土壤模拟溶液中应力腐蚀行为的影响[J]. 金属学报, 2017, 53(7): 797-807.
[9] 董利明,杨莉,戴军,张宇,王学林,尚成嘉. Mn、Ni、Mo含量对K65热煨弯管焊缝组织转变和低温韧性的影响[J]. 金属学报, 2017, 53(6): 657-668.
[10] 万红霞,宋东东,刘智勇,杜翠薇,李晓刚. 交流电对X80钢在近中性环境中腐蚀行为的影响[J]. 金属学报, 2017, 53(5): 575-582.
[11] 闫茂成,杨霜,许进,孙成,吴堂清,于长坤,柯伟. 酸性土壤中破损防腐层下X80管线钢的应力腐蚀行为*[J]. 金属学报, 2016, 52(9): 1133-1141.
[12] 刘智勇,李宗书,湛小琳,皇甫文珠,杜翠薇,李晓刚. X80钢在鹰潭土壤模拟溶液中应力腐蚀裂纹扩展行为机理*[J]. 金属学报, 2016, 52(8): 965-972.
[13] 宋峰雨,李艳梅,王平,朱伏先. 热输入量对一种新型药芯焊丝熔敷金属组织及冲击韧性的影响*[J]. 金属学报, 2016, 52(7): 890-896.
[14] 王学林,董利明,杨玮玮,张宇,王学敏,尚成嘉. Mn/Ni/Mo配比对K65管线钢焊缝金属组织与力学性能的影响*[J]. 金属学报, 2016, 52(6): 649-660.
[15] 张子龙, 夏爽, 曹伟, 李慧, 周邦新, 白琴. 晶界特征对316不锈钢沿晶应力腐蚀开裂裂纹萌生的影响*[J]. 金属学报, 2016, 52(3): 313-319.