Please wait a minute...
金属学报  2010, Vol. 46 Issue (8): 1009-1017    DOI: 10.3724/SP.J.1037.2009.00869
  论文 本期目录 | 过刊浏览 |
带钢热连轧机工作辊非稳态传热的数值模拟
冯明杰,王恩刚,赫冀成
东北大学材料电磁过程研究教育部重点实验室, 沈阳 110819
NUMERICAL SIMULATION ON UNSTEADY STATE HEAT TRASFER OF WORK ROLLS DURING CONTINUOUS HOT STRIP ROLLING
FENG Mingjie, WANG Engang, HE Jicheng
Key Laboratory of National Education Ministry for Electromagnetic Processing of Materials, Northeastern University, Shenyang 110819
引用本文:

冯明杰 王恩刚 赫冀成. 带钢热连轧机工作辊非稳态传热的数值模拟[J]. 金属学报, 2010, 46(8): 1009-1017.
, , . NUMERICAL SIMULATION ON UNSTEADY STATE HEAT TRASFER OF WORK ROLLS DURING CONTINUOUS HOT STRIP ROLLING[J]. Acta Metall Sin, 2010, 46(8): 1009-1017.

全文: PDF(1397 KB)  
摘要: 

以Flunet 6.3为平台, 利用多重坐标系和自定义函数功能, 研究了3种常用复合轧辊在带钢热连轧过程中的非稳态温度波和热流波的传播特点, 并对其引起的热冲击现象进行了探讨. 结果表明, 辊内的温度分布和传播特点可以分为高频和低频2种非稳态温度波来进行研究. 高频温度波随着深度的增加快速衰减, 最大影响深度不超过7.5 mm,而低频温度波衰减较慢, 深度超过了20 mm. 热冲击随着深度的增加而快速减小,在同样的条件下, 高速钢复合轧辊的热冲击深度最大, 而高Ni--Cr铸铁复合轧辊的热冲击深度最小. 随着轧钢块数的增加, 工作辊每轧制一块带坯的吸热量减少,散热量增加, 留存的热量减少.

关键词 热轧 复合轧辊 温度波 热冲击 热流波    
Abstract

The spreading properties of unsteady state temperature wave, heating flux wave and heating shock phenomena during continuous hot slab rolling have been numerically simulated for three types of commonly used composite rolls by use of various coordinate systems and user–defined functions based on Fluent 6.3 software. The results indicate that the temperature wave can be divided into a high–frequency and low–frequency unsteady state temperature wave to describe the temperature distribution and spreading properties in rolls. It is found that the wave amplitude of the high–frequency temperature wave will quickly decrease with the increase of propagation depth, and its propagation depth of maximum impact is less than 7.5 mm. But, under the same rolling conditions, the amplitude attenuation of the low–frequency temperature wave is slower, and its propagation depth of impact is more than 20 mm. The heating shock decreases rapidly with the increase of distance from the surface of work roll. The heating shock depth is the deepest for the high speed steel composite roll, but the shallowest for the high nicked chromium cast iron composite roll under the same rolling conditions. The absorbed and resided heat by work–rolls during each slab hot rolling is down, but the dissipated heat by rolls is up with rolled slab number increasing.

Key wordshot rolling    composite roll    temperature wave    heating shock    heating flux wave
收稿日期: 2009-12-30     
基金资助:

国家高技术研究发展计划项目2003AA331050和国家自然科学基金项目200809123资助

作者简介: 冯明杰, 男, 1971年生, 讲师, 博士

[1] Twadoh S, Mori T. ISIJ Int, 1992; 32: 1131
[2] Kudo T, Kawashima S, Kurahashi R. ISIJ Int, 1992; 32: 1190
[3] Parke D M, Baker L L. Iron Steel Eng, 1972; 211: 83
[4] Devadas C, Samarasekara V. Ironmaking Steelmaking, 1986; 13: 311
[5] Teseng A A, Lin F H, Gunderia A S, Ni D S. Metall Trans, 199020A: 2305
[6] Lin Z, Chen C. Mater Process Technol, 1995; 49: 125
[7] Guo Z F, Xu J Z, Li C S, Liu X H. Northeast Univ (Nat Sci), 2008; 29: 517
(郭忠峰, 徐建忠, 李长生, 刘相华. 东北大学学报(自然科学版), 2008; 29: 517)
[8] Yang L P, Liu H M, Peng Y, Wang Y R. Iron Steel, 2005; 40(10): 38
(杨利坡, 刘宏民, 彭艳, 王英睿. 钢铁, 2005; 40(10): 38)
[9] Wang L Y, Wang Y K, Iron Steel, 1995; 30(5): 22
(汪凌云, 王业科. 钢铁, 1995; 30(5): 22)
[10] Guo Z F, Li C S, Xu J Z, Liu X H, Wang G D. Iron Steel Res, 2006; 13(6): 27
[11] Chen B G, Chen X L. Iron Steel, 1991; 26(8): 40
(陈宝官, 陈先霖. 钢铁, 1991; 26(8): 40)
[12] Gao J H, Huang C Q, Wang M, Huang J P. Plast Eng, 2009; 16: 218
(高建红, 黄传清, 王敏, 黄建平. 塑性工程学报, 2009; 16: 218)
[13] Du F S, Yu H, Guo Z N. Plast Eng, 2005; 12: 78
(杜凤山, 于辉, 郭振宁. 塑性工程学报, 2005; 12: 78)
[14] Serajzadeh A, Taheri A K, Mucciardi F. Int Mech Sci, 2002; 44: 2447
[15] Saboonchi A, Abbaspour M. Mater Process Technol, 2004; 148: 35

[1] 程远遥, 赵刚, 许德明, 毛新平, 李光强. 奥氏体化温度对Si-Mn钢热轧板淬火-配分处理后显微组织和力学性能的影响[J]. 金属学报, 2023, 59(3): 413-423.
[2] 姜伟宁, 武晓龙, 杨平, 顾新福, 解清阁. 热轧硅钢表层动态再结晶区形成规律及剪切织构特征[J]. 金属学报, 2022, 58(12): 1545-1556.
[3] 刘后龙,马明玉,刘玲玲,魏亮亮,陈礼清. 热轧板退火工艺对19Cr2Mo1W铁素体不锈钢织构与成形性能的影响[J]. 金属学报, 2019, 55(5): 566-574.
[4] 郭策安, 陈明辉, 廖依敏, 苏北, 谢冬柏, 朱圣龙, 王福会. 模拟燃气热冲击条件下搪瓷基复合涂层的防护机理研究[J]. 金属学报, 2018, 54(12): 1825-1832.
[5] 何承绪,杨富尧,严国春,孟利,马光,陈新,毛卫民. 常化处理对薄规格取向硅钢织构的影响*[J]. 金属学报, 2016, 52(9): 1063-1069.
[6] 刘梦莹, 常海, 徐锋, 许正芳, 杨昭, 王宁, 甘为民, 冯强. 冷床炉熔炼TC1合金轧制过程中组织演变与力学性能*[J]. 金属学报, 2015, 51(3): 341-348.
[7] 喇培清,孟倩,姚亮,周毛熊,魏玉鹏. Al元素对热轧316L不锈钢显微组织和力学性能的影响[J]. 金属学报, 2013, 49(6): 739-744.
[8] 刚建伟,施斌卿,陈荣石,柯伟. 热轧Mg-1Zn和Mg-1Y合金退火组织演变及静态再结晶行为[J]. 金属学报, 2012, 48(5): 526-533.
[9] 颜孟奇 钱浩 杨平 宋惠军 邵媛媛 毛卫民. 电工钢中黄铜织构行为及其对Goss织构的影响[J]. 金属学报, 2012, 48(1): 16-22.
[10] 冯明杰 王恩刚 赫冀成. 高速钢复合轧辊连铸复合过程温度场的数值模拟 I. 石墨铸型法[J]. 金属学报, 2011, 47(12): 1495-1502.
[11] 冯明杰 王恩刚 赫冀成. 高速钢复合轧辊连铸复合过程温度场的数值模拟 II. 铜结晶器法[J]. 金属学报, 2011, 47(12): 1503-1512.
[12] 谢红飙 高亚男 王涛 肖宏. 多道次热轧对包层钢筋性能及结合面的影响[J]. 金属学报, 2011, 47(12): 1513-1519.
[13] 尹云洋 杨王玥 李龙飞 孙祖庆 王西涛. 基于过冷奥氏体动态相变的热轧TRIP钢组织控制 II. 动态相变后冷却速率[J]. 金属学报, 2010, 46(2): 161-166.
[14] 尹云洋 杨王玥 李龙飞 孙祖庆 王西涛. 基于过冷奥氏体动态相变的热轧TRIP钢组织控制  I.原始奥氏体晶粒尺寸[J]. 金属学报, 2010, 46(2): 155-160.
[15] 马宁博; 雷作胜; 金小礼; 操光辉; 钟云波; 任忠鸣 . 温度波动对包晶钢连铸初始凝固过程的影响[J]. 金属学报, 2008, 44(8): 1019-1024 .