|
|
EFFECT OF A HIGH STATIC MAGNETIC FIELD ON MICROSEGREGATION OF DIRECTIONALLY SOLIDIFIED Al-4.5Cu ALLOY |
Hua ZHONG,Chuanjun LI,Jiang WANG,Zhongming REN( ),Yunbo ZHONG,Weidong XUAN |
State Key Laboratory of Advanced Special Steel, Shanghai University, Shanghai 200072, China |
|
Cite this article:
Hua ZHONG,Chuanjun LI,Jiang WANG,Zhongming REN,Yunbo ZHONG,Weidong XUAN. EFFECT OF A HIGH STATIC MAGNETIC FIELD ON MICROSEGREGATION OF DIRECTIONALLY SOLIDIFIED Al-4.5Cu ALLOY. Acta Metall Sin, 2016, 52(5): 575-582.
|
Abstract Microsegregation is the unbalanced distribution of alloying element between solid and liquid phases in dendritic scale during solidification. The solute redistribution usually leads to the formation of brittle secondary phase, which is harmful to the workability and final mechanical properties of casting component. It has been accepted that fluid flow plays a critical role in mass transfer during solidification and thus altering the microsegregation pattern. High static magnetic field has been considered as an effective way to control the convection in solidification. In this work, the impact of the high static magnetic field on the microsegregation was investigated. Al-4.5Cu (mass fraction, %) alloy was directionally solidified from <001> seed crystal under various magnetic fields with a constant pulling rate of 50 μm/s and temperature gradient of 101 K/cm. OM and BSE were applied to characterize the microstructure of the solidified samples. The fraction of Al2Cu second phase was obtained by software analysis from the transverse and longitudinal sections. The results show that the Al-4.5Cu alloy solidifies in dendritic morphology. The formation of second phase is significantly affected by the magnetic field. Without magnetic field, the continuous network of second phase is observed at grain boundaries. In the presence of the magnetic field, the second phase is disconnected in the grain boundaries and dispersed in grains. The fraction of the second phase is reduced with the increase of the magnetic field. EDS area scan was carried out to measure the concentration of Cu solute in dendritic scale. Isoconcentration contour maps of Cu in the plane perpendicular to the primary dendrite trunk were drawn. The concentration profiles of Cu were plotted from the measured data and the effective partition coefficient ke was calculated. It is found that the redistribution of Cu solute in interdendritic region is greatly altered by the magnetic field. When the intensity of the magnetic field increases, the concentration profile and the ke decrease. The disturbance of the Cu solute in the plane perpendicular to the primary trunk suggests the existence of fluid flow in the interdendritic region. The above phenomena could be attributed to the dendritic scale thermoelectric magnetic convection (TEMC) as well as the second flow driven by the TEMC. The azimuthal TEMC and meridional second flow will bring about stirring in mushy zone and lead to the modification of solute transport during solidification process.
|
Received: 08 October 2015
|
Fund: Supported by National Basic Research Program of China (No.2011CB010404), National Natural Science Foundation of China (Nos.51404148 and 51401116) and Shanghai Science and Technology Committee Grant (Nos.13DZ1108200, 13521101102 and 14521102900) |
[1] | Chalmers B.Principles of Solidification. New York: John Wiley & Sons, 1964: 15 | [2] | Kurz W, Fisher D J.Fundamentals of Solidification. Aedermannsdorf: Trans Tech Publications, 1986: 13 | [3] | Fu H Z, Guo J J, Liu L, Li J S.Directional Solidification and Processing of Advanced Materials. Beijing: Science Press, 2008: 79 | [3] | (傅恒志, 郭景杰, 刘林, 李金山, 先进材料定向凝固. 北京: 科学出版社, 2008: 79) | [4] | Rudolph P, Kakimoto K.MRS Bull, 2009; 34: 251 | [5] | Davidson P A.Annu Rev Fluid Mech, 1999; 31: 273 | [6] | Noeppel A, Ciobanas A, Wang X D, Zaidat K, Mangelinck N, Budenkova O, Weiss A, Zimmermann G, Fautrelle Y.Metall Mater Trans, 2010; 41B: 193 | [7] | Umeda T, Thirathipviwat P, Supradist M, Nagaumi H.Int J Cast Met Res, 2011; 24: 184 | [8] | Eckert S, Nikrityuk P, Willers B, R?biger D, Shevchenko N, Neumann-Heyme H, Travnikov V, Odenbach S, Voigt A, Eckert K.Euro Phys J Spec Topics, 2013; 220: 123 | [9] | Flemings M.Metall Trans, 1991; 22A: 957 | [10] | Xuan W D, Ren Z M, Li C J, Ren W L, Cheng C, Yu Z.Acta Metall Sin, 2012; 48: 629 | [10] | (玄伟东, 任忠鸣, 李传军, 任维丽, 陈超, 于湛. 金属学报, 2012; 48: 629) | [11] | Kaldre I, Fautrelle Y, Etay J, Bojarevics A, Buligins L.J Alloys Compd, 2013; 571: 50 | [12] | Li X, Du D F, Gagnoud A, Ren Z M, Fautrelle Y, Moreau R.Metall Mater Trans, 2014; 45A: 5584 | [13] | Guan G, Du D, Fautrelle Y, Moreau R, Ren Z M, Li X.Europhys Lett, 2015; 111: 28004 | [14] | Shercliff J A. J Fluid Mech, 1979; 91: 231 | [15] | Jaworski M A, Gray T K, Antonelli M, Kim J J, Lau C Y, Lee M B, Neumann M J, Xu W, Ruzic D N.Phys Rev Lett, 2010; 104: 094503 | [16] | Lehmann P, Moreau R, Camel D, Bolcato R.Acta Mater, 1998; 46: 4067 | [17] | Kao A, Pericleous K.In: Ludwig A ed., 13th International Conference on Modeling of Casting, Welding and Advanced Solidification Processes, Schladming: IOP Conference Series, 2012; 33: 012045 | [18] | Yasuda H, Minami Y, Nagira T, Yoshiya M, Uesugi K, Umetani K.J Iron Steel Res Int, 2012; 19: 34 | [19] | Wang J, Fautrelle Y, Ren Z M, Nguyen-Thi H, Salloum Abou Jaoude G, Reinhart G, Mangelinck-No?l N, Li X, Kaldre I.Appl Phys Lett, 2014; 104: 121916 | [20] | Tewari S N, Shah R, Song H.Metall Mater Trans, 1994; 25A: 1535 | [21] | Dold P, Szofran F R, Benz K W.J Cryst Growth, 2006; 291: 1 | [22] | Ren W L, Lu L, Yuan G, Xuan W, Zhong Y, Yu J, Ren Z M.Mater Lett, 2013; 100: 223 | [23] | Li X, Gagnoud A, Ren Z M, Fautrelle Y, Debray F.J Mater Res, 2013; 28: 2810 | [24] | Yang C B, Liu L, Zhao X B, Liu G, Zhang J, Fu H Z.Acta Metall Sin, 2011; 10: 1246 | [24] | (杨初斌, 刘林, 赵新宝, 刘刚, 张军, 傅恒志. 金属学报, 2011; 10: 1246) | [25] | Henry S, Minghetti T, Rappaz M.Acta Mater, 1998; 46: 6431 | [26] | Ganesan M, Thuinet L, Dye D, Lee P D.Metall Mater Trans, 2007; 38B: 557 | [27] | Sheil E.Z Metallkd, 1941; 34: 70 | [28] | Youdelis W V, Colton D R, Cahoon J.Can J Phys, 1964; 42: 2217 | [29] | Martin J W, Doherty R D, Cantor B.Stability of Microstructure in Metallic Systems. 2nd Ed., Cambridge: Cambridge University Press, 1997: 391 | [30] | Wang J, Fautrelle Y, Nguyen-Thi H, Reinhart G, Liao H, Zhong Y B, Ren Z M.Metall Mater Trans, 2016; 47A: 1169 |
|
No Suggested Reading articles found! |
|
|
Viewed |
|
|
|
Full text
|
|
|
|
|
Abstract
|
|
|
|
|
Cited |
|
|
|
|
|
Shared |
|
|
|
|
|
Discussed |
|
|
|
|