Please wait a minute...
Acta Metall Sin  2025, Vol. 61 Issue (4): 608-618    DOI: 10.11900/0412.1961.2023.00149
Research paper Current Issue | Archive | Adv Search |
Microcrack Nucleation and Propagation of TRIP-Assisted Duplex Stainless Steel Fe-19.6Cr-2Ni-2.9Mn-1.6Si
ZHANG Wenbin1, LI Xiaolong1, HAO Shuo1, LIU Shengjie1, CAI Xingzhou1, CHEN Lei1,2, JIN Miao1()
1 College of Mechanical Engineering, Yanshan University, Qinhuangdao 066004, China
2 National Engineering Research Center for Equipment and Technology of Cold Strip Rolling, Yanshan University, Qinhuangdao 066004, China
Cite this article: 

ZHANG Wenbin, LI Xiaolong, HAO Shuo, LIU Shengjie, CAI Xingzhou, CHEN Lei, JIN Miao. Microcrack Nucleation and Propagation of TRIP-Assisted Duplex Stainless Steel Fe-19.6Cr-2Ni-2.9Mn-1.6Si. Acta Metall Sin, 2025, 61(4): 608-618.

Download:  HTML  PDF(3378KB) 
Export:  BibTeX | EndNote (RIS)      
Abstract  

The transformation-induced plasticity (TRIP) effect considerably enhances the material properties of TRIP-assisted duplex steel due to the martensitic transformation. However, as martensitic transformation progresses, a complex microstructure forms from the intermixing of three phases (i.e., austenite, ferrite, and martensite) in the steel, which results in complex damage behavior, crack nucleation, and propagation characteristics. In this study, under engineering strain up to 55%, TRIP-assisted duplex stainless steel Fe-19.6Cr-2Ni-2.9Mn-1.6Si was characterized to investigate microcrack characteristics. Herein, different types of microcracks were statistically categorized using SEM. Additionally, microcrack nucleation and propagation laws were analyzed in light of microscopic features characterized by EBSD, including phase distribution and grain and phase boundaries. The results show that the majority of microcracks are situated at the phase boundary between original austenite and ferrite, constituting about 70% of all microcracks. The number of microcracks located at the ferrite grain boundary accounts for about 20% of the total, while the number of microcracks located at the original austenite grain boundary accounts for only about 10% of the total. The interface between martensite and ferrite emerged as the primary site for microcrack nucleation. Furthermore, the study identifies three distinct microcrack nucleation sites influenced by various boundary types: at the intersection of martensite, ferrite, and austenite phases; at the junction of martensite/ferrite phase boundary and ferrite grain boundary; and at the cross point of martensite/ferrite phase boundary and the original austenite grain boundary. Therefore, microcracks might propagate along the original austenite/ferrite phase boundary or ferrite grain boundary with a smaller angle (< 30°) to the phase boundary. In addition, microcracks are less apt to propagate along the austenite grain boundary.

Key words:  TRIP-assisted duplex stainless steel      microcrack      crack nucleation      crack propagation      transformed martensite     
Received:  03 April 2023     
ZTFLH:  TG142.1  
Fund: National Natural Science Foundation of China(52275388, 52075474);Natural Science Foundation of Hebei Province(E2022203206);Cultivation Project for Basic Research and Innovation of Yanshan University(2021LGZD009, 2022BZZD002)
Corresponding Authors:  JIN Miao, professor, Tel: (0335)8056775, E-mail: jmiao@ysu.edu.cn

URL: 

https://www.ams.org.cn/EN/10.11900/0412.1961.2023.00149     OR     https://www.ams.org.cn/EN/Y2025/V61/I4/608

Fig.1  Schematic of sample (a) and observation area for SEM and distribution of microcracks (b) (unit: mm)
Fig.2  Initial microstructure of the as-received Fe-19.6Cr-2Ni-2.9Mn-1.6Si steel
(a) SEM image (b) phase distribution (c) inverse pole figure (IPF)
Fig.3  Mechanical properties of Fe-19.6Cr-2Ni-2.9Mn-1.6Si steel during monotonic loading (σE—engineering stress, εE—engineering strain, σ—true stress, ε—true strain, θ—work hardening rate, εf— instability strain)
(a) engineering stress-engineering strain curve
(b) true stress-true strain and work hardening rate curves
Fig.4  Statistics of microcrack locations of Fe-19.6Cr-2Ni-2.9Mn-1.6Si steel
(a-g) microcracks at phase boundary
(h) microcracks at original austenite grain boundary (i, j) microcracks at ferrite grain boundary (k) statistical pie chart
Fig.5  Characteristics of microcracks at the original austenite/ferrite phase boundary
(a) SEM image
(b) phase distribution
(c) IPF
Fig.6  Nucleation of a microcrack at the original austenite/ferrite phase boundary and the propagation trend of the microcrack along the ferrite grain boundary
(a) SEM image
(b) phase distribution
(c) IPF
Fig.7  Propagation characteristics of a microcrack on the original austenite/ferrite phase boundary
(a) SEM image
(b) phase distribution
(c) IPF
Fig.8  Characteristics of a microcrack on ferrite grain boundary
(a) SEM image
(b) phase distribution
(c) IPF
Fig.9  Characteristics of microcracks at original austenite grain boundary
(a) SEM image (b) phase distribution (c) IPF
Fig.10  Schematics of microcrack nucleation characteristics
(a) nucleation at the intersection position of transformed martensite/ferrite/residual austenite
(b) nucleation at the intersection position of the ferrite/martensite phase boundary and ferrite grain boundary
(c) nucleation at the intersection of ferrite/martensite phase boundary and original austenite grain boundary
Fig.11  Schematics of crack propagation paths
(a) crack propagation along the original austenite/ferrite phase boundary
(b) crack propagation along ferrite grain boundary with a smaller angle to the phase boundary
(c) crack propagation along transformed martensite (original austenite) grain boundary
Fig.12  Schematics of non-nucleated crack at austenite/martensite phase boundary
(a) deformation of pre nucleated martensite and austenite
(b) formation of new phase boundaries due to martensite growth
1 Li Y, Zhong S X, Luo H, et al. Intermediate stacking fault and twinning induced cooperative strain evolution of dual phase in lean duplex stainless steels with excellent cryogenic strength-ductility combinations [J]. Mater. Sci. Eng., 2022, A831: 142347
2 Kang J Y, Kim H, Kim K I, et al. Effect of austenitic texture on tensile behavior of lean duplex stainless steel with transformation induced plasticity (TRIP) [J]. Mater. Sci. Eng., 2017, A681: 114
3 Herrera C, Ponge D, Raabe D. Design of a novel Mn-based 1 GPa duplex stainless TRIP steel with 60% ductility by a reduction of austenite stability [J]. Acta Mater., 2011, 59: 4653
4 Srivastava A, Ghassemi-Armaki H, Sung H, et al. Micromechanics of plastic deformation and phase transformation in a three-phase TRIP-assisted advanced high strength steel: Experiments and modeling [J]. J. Mech. Phys. Solids, 2015, 78: 46
5 Soleimani M, Kalhor A, Mirzadeh H. Transformation-induced plasticity (TRIP) in advanced steels: A review [J]. Mater. Sci. Eng., 2020, A795: 140023
6 Su X F, Chen H R, Kennedy D, et al. Effects of interphase strength on the damage modes and mechanical behaviour of metal-matrix composites [J]. Composites, 1999, 30A: 257
7 Sun X, Choi K S, Soulami A, et al. On key factors influencing ductile fractures of dual phase (DP) steels [J]. Mater. Sci. Eng., 2009, A526: 140
8 Saai A, Hopperstad O S, Granbom Y, et al. Influence of volume fraction and distribution of martensite phase on the strain localization in dual phase steels [J]. Proc. Mater. Sci., 2014, 3: 900
9 Tasan C C, Hoefnagels J P M, Diehl M, et al. Strain localization and damage in dual phase steels investigated by coupled in-situ deformation experiments and crystal plasticity simulations [J]. Int. J. Plast., 2014, 63: 198
10 Motoyashiki Y, Brückner-Foit A, Sugeta A. Microstructural influence on small fatigue cracks in a ferritic-martensitic steel [J]. Eng. Fract. Mech., 2008, 75: 768
11 Xie Q G, Lian J H, Sun F W, et al. The lattice strain ratio in characterizing the grain-to-grain interaction effect and its specific insight on the plastic deformation of polycrystalline materials [J]. J. Strain Anal. Eng. Des., 2018, 53: 353
12 Morsdorf L, Jeannin O, Barbier D, et al. Multiple mechanisms of lath martensite plasticity [J]. Acta Mater., 2016, 121: 202
13 Du C, Hoefnagels J P M, Vaes R, et al. Plasticity of lath martensite by sliding of substructure boundaries [J]. Scr. Mater., 2016, 120: 37
14 Calcagnotto M, Adachi Y, Ponge D, et al. Deformation and fracture mechanisms in fine- and ultrafine-grained ferrite/martensite dual-phase steels and the effect of aging [J]. Acta Mater., 2011, 59: 658
15 Park K, Nishiyama M, Nakada N, et al. Effect of the martensite distribution on the strain hardening and ductile fracture behaviors in dual-phase steel [J]. Mater. Sci. Eng., 2014, A604: 135
16 Paul S K. Real microstructure based micromechanical model to simulate microstructural level deformation behavior and failure initiation in DP 590 steel [J]. Mater. Des., 2013, 44: 397
17 Marvi-Mashhadi M, Mazinani M, Rezaee-Bazzaz A. FEM modeling of the flow curves and failure modes of dual phase steels with different martensite volume fractions using actual microstructure as the representative volume [J]. Comput. Mater. Sci., 2012, 65: 197
18 Cheloee Darabi A, Kadkhodapour J, Pourkamali Anaraki A, et al. Micromechanical modeling of damage mechanisms in dual-phase steel under different stress states [J]. Eng. Fract. Mech., 2021, 243: 107520
19 Yuenyong J, Uthaisangsuk V. Micromechanics based modelling of fatigue crack initiation of high strength steel [J]. Int. J. Fatigue, 2020, 139: 105762
20 Darabi A C, Guski V, Butz A, et al. A comparative study on mechanical behavior and damage scenario of DP600 and DP980 steels [J]. Mech. Mater., 2020, 143: 103339
21 Alaie A, Ziaei Rad S, Kadkhodapour J, et al. Effect of microstructure pattern on the strain localization in DP600 steels analyzed using combined in-situ experimental test and numerical simulation [J]. Mater. Sci. Eng., 2015, A638: 251
22 Zhang J C, Di H S, Deng Y G, et al. Effect of martensite morphology and volume fraction on strain hardening and fracture behavior of martensite-ferrite dual phase steel [J]. Mater. Sci. Eng., 2015, A627: 230
23 Archie F, Li X L, Zaefferer S. Micro-damage initiation in ferrite-martensite DP microstructures: A statistical characterization of crystallographic and chemical parameters [J]. Mater. Sci. Eng., 2017, A701: 302
24 Moallemi M, Kim S J, Zarei-Hanzaki A, et al. Strain hardening analysis and deformation micromechanisms in high strength-high ductility metastable duplex stainless steels: Role of sustained stacking faults in the work hardening [J]. Mater. Charact., 2023, 197: 112662
25 Connolly D S, Kohar C P, Mishra R K, et al. A new coupled thermomechanical framework for modeling formability in transformation induced plasticity steels [J]. Int. J. Plast., 2018, 103: 39
26 Kim E Y, Woo W C, Heo Y U, et al. Effect of kinematic stability of the austenite phase on phase transformation behavior and deformation heterogeneity in duplex stainless steel using the crystal plasticity finite element method [J]. Int. J. Plast., 2016, 79: 48
27 Yasnikov I S, Vinogradov A, Estrin Y. Revisiting the Considère criterion from the viewpoint of dislocation theory fundamentals [J]. Scr. Mater., 2014, 76: 37
28 Zhang H Y. Transformation-induced plasticity characteristics and temperature dependence of Cr20Mn3Cu2NiN lean duplex stainless steel [D]. Qinhuangdao: Yanshan University, 2023
张寰宇. Cr20Mn3Cu2NiN节约型双相不锈钢相变诱导塑性特征及其温度依赖性 [D]. 秦皇岛: 燕山大学, 2023
29 Gu G H, Seo M H, Suh D W, et al. Observation of multi-scale damage evolution in transformation-induced plasticity steel under bending condition [J]. Mater. Today Commun., 2023, 34: 105291
30 Kang J, Ososkov Y, Embury J D, et al. Digital image correlation studies for microscopic strain distribution and damage in dual phase steels [J]. Scr. Mater., 2007, 56: 999
31 Lian J H, Yang H Q, Vajragupta N, et al. A method to quantitatively upscale the damage initiation of dual-phase steels under various stress states from microscale to macroscale [J]. Comput. Mater. Sci., 2014, 94: 245
32 Han Q H, Kang Y L, Hodgson P D, et al. Quantitative measurement of strain partitioning and slip systems in a dual-phase steel [J]. Scr. Mater., 2013, 69: 13
33 Das A, Tarafder S, Sivaprasad S, et al. Influence of microstructure and strain rate on the strain partitioning behaviour of dual phase steels [J]. Mater. Sci. Eng., 2019, A754: 348
34 Feng R, Zhang M H, Chen N L, et al. Finite element simulation of the effect of stress relaxation on strain-induced martensitic transformation [J]. Acta Metall. Sin., 2014, 50: 498
doi: 10.3724/SP.J.1037.2013.00559
冯 瑞, 张美汉, 陈乃录 等. 应力松弛对应变诱发马氏体相变影响的有限元模拟 [J]. 金属学报, 2014, 50: 498
[1] JIANG He, NAI Qiliang, XU Chao, ZHAO Xiao, YAO Zhihao, DONG Jianxin. Sensitive Temperature and Reason of Rapid Fatigue Crack Propagation in Nickel-Based Superalloy[J]. 金属学报, 2023, 59(9): 1190-1200.
[2] LI Xifeng, LI Tianle, AN Dayong, WU Huiping, CHEN Jieshi, CHEN Jun. Research Progress of Titanium Alloys and Their Diffusion Bonding Fatigue Characteristics[J]. 金属学报, 2022, 58(4): 473-485.
[3] ZHOU Hongwei, BAI Fengmei, YANG Lei, CHEN Yan, FANG Junfei, ZHANG Liqiang, YI Hailong, HE Yizhu. Low-Cycle Fatigue Behavior of 1100 MPa Grade High-Strength Steel[J]. 金属学报, 2020, 56(7): 937-948.
[4] ZHANG Xiaochen, MENG Weiying, ZOU Defang, ZHOU Peng, SHI Huaitao. Effect of Pre-Cyclic Stress on Fatigue Crack Propagation Behavior of Key Structural Al Alloy Materials Used in High Speed Trains[J]. 金属学报, 2019, 55(10): 1243-1250.
[5] Jin WANG, Liming YU, Yuan HUANG, Huijun LI, Yongchang LIU. Effect of Crystal Orientation and He Density on Crack Propagation Behavior of bcc-Fe[J]. 金属学报, 2018, 54(1): 47-54.
[6] Shu GUO,En-Hou HAN,Haitao WANG,Zhiming ZHANG,Jianqiu WANG. Life Prediction for Stress Corrosion Behavior of 316L Stainless Steel Elbow of Nuclear Power Plant[J]. 金属学报, 2017, 53(4): 455-464.
[7] Jin WANG, Yuefei ZHANG, Jinyao MA, Jixue LI, Ze ZHANG. Microcrack Nucleation and Propagation Investigation ofInconel 740H Alloy Under In SituHigh Temperature Tensile Test[J]. 金属学报, 2017, 53(12): 1627-1635.
[8] Zhiyong LIU,Zongshu LI,Xiaolin ZHAN,Wenzhu HUANGFU,Cuiwei DU,Xiaogang LI. GROWTH BEHAVIOR AND MECHANISM OF STRESS CORROSION CRACKS OF X80 PIPELINE STEEL IN SIMULATED YINGTAN SOIL SOLUTION[J]. 金属学报, 2016, 52(8): 965-972.
[9] ZHU Chunlei, LI Sheng, LI Haizhao, ZHANG Ji. EFFECT OF THERMAL EXPOSURE AT 750 ℃ ON ROOM TEMPERATURE TENSILE DUCTILITY OF CAST TiAl ALLOY WITH DIRECTIONAL LAMELLAR MICROSTRUCTURE[J]. 金属学报, 2014, 50(12): 1478-1484.
[10] YU Long, SONG Xiping, ZHANG Min, LI Hongliang, JIAO Zehui, YU Huichen. CRACK INITIATION AND PROPAGATION OF HIGH Nb-CONTAINING TiAl ALLOY IN FATIGUE-CREEP INTERACTION[J]. 金属学报, 2014, 50(10): 1253-1259.
[11] JIANG Bing XING Xianran GUO Zhimeng. CRACK PROPAGATION AND DOMAIN SWITCHING IN BaTiO3 SINGLE CRYSTALS UNDER EXTERNAL FIELD[J]. 金属学报, 2011, 47(5): 605-610.
[12] ZHOU Yanlei XU Yang CHEN Jun LIU Zhenyu. EXPERIMENTAL STUDY OF THE IMPACT FRACTURE BEHAVIOR OF FH550 OFFSHORE PLATFORM STEEL[J]. 金属学报, 2011, 47(11): 1382-1387.
[13] YU Huichen; SUN Yanguo; XIE Shishu; K. TANAKA. Low Cycle Fatigue Crack Propagation in Stainless Steel Under Combined Torsion and Tension[J]. 金属学报, 2005, 41(1): 73-.
[14] LI Hangyue; HU Naisai; HE Jiawen; ZHOU Huijiu(State Key Laboratory for Mechanical Behaviour of Metallic Materialas; Xi'an Jiaotong University; Xi'an 710049)Correspondent: HE Jiawen; professor Tel: (029)3268696; Fax: (029)3237910;E-mail: jwhe xjtudu. cn.. AN ANALYTICAL MODEL OF COMPRESSIVE RESIDUAL STRESS EFFECT ON CLOSURE[J]. 金属学报, 1998, 34(8): 847-851.
[15] XING Li; KE Liming (Nanchang Institute of Aero-Technology; Nanchang 330034). HYDROGEN INDUCED FRACTURE IN WELD METAL OF FERRITE-AUSTENITE DUPLEX STAINLESS STEEL[J]. 金属学报, 1997, 33(3): 297-303.
No Suggested Reading articles found!