Please wait a minute...
金属学报  2015, Vol. 51 Issue (7): 769-776    DOI: 10.11900/0412.1961.2014.00665
  本期目录 | 过刊浏览 |
取向硅钢中 114 418 织构对二次再结晶时晶粒异常长大的影响*
刘志桥,杨平(),毛卫民,崔凤娥
EFFECT OF 114 418 TEXTURE ON ABNORMAL GROWTH DURING SECONDARY RECRYSTALLI- ZATION IN GRAIN-ORIENTED STEEL
Zhiqiao LIU,Ping YANG(),Weimin MAO,Feng'e CUI
School of Materials Science and Engineering, University of Science and Technology Beijing, Beijing 100083
引用本文:

刘志桥,杨平,毛卫民,崔凤娥. 取向硅钢中 114 418 织构对二次再结晶时晶粒异常长大的影响*[J]. 金属学报, 2015, 51(7): 769-776.
Zhiqiao LIU, Ping YANG, Weimin MAO, Feng'e CUI. EFFECT OF 114 418 TEXTURE ON ABNORMAL GROWTH DURING SECONDARY RECRYSTALLI- ZATION IN GRAIN-ORIENTED STEEL[J]. Acta Metall Sin, 2015, 51(7): 769-776.

全文: PDF(7562 KB)   HTML
摘要: 

运用EBSD技术观察HiB钢在大压下率冷轧条件下薄规格样品的二次再结晶行为, 从而研究薄规格样品二次再结晶难以发生的原因. 通过渗氮处理添加抑制剂使二次再结晶能顺利发生, 并研究渗氮量对薄规格样品二次再结晶的影响, 以及 114 418 织构对黄铜与Goss取向晶粒异常长大的影响. 结果表明, 在二次再结晶退火时, 相对于其它取向的晶粒, 两侧表层的 114 418 取向附近的晶粒具有明显的长大优势, 并向中心层生长, 如果样品表层抑制剂强度不足, 其容易长大到样品的中心层吞并掉二次再结晶的核心而不利于二次再结晶的发生, 经渗氮补充抑制剂后能有效抑制表层晶粒的长大, 从而有利于二次再结晶的发生和磁性能的提高; 在二次再结晶初期, 114 418 取向附近的晶粒容易保留在发生异常长大的偏转Goss取向晶粒和黄铜取向晶粒的中心处并形成岛晶而不利于它们的异常长大, 但该取向的晶粒对Goss取向晶粒异常长大的影响较小.

关键词 114 418 织构薄规格取向硅钢异常长大抑制剂    
Abstract

To find out the reason of poor secondary recrystallization behavior in thin-gauged grain-oriented steel, EBSD technique is applied to reveal the grain growth behavior of thin-gauged steel processed by HiB steel method under high cold-rolling reduction. Nitriding treatment with different times is conducted to ensure the occurrence of secondary recrystallization in thin-gauged grain-oriented steel and to determine the effect of nitrogen content. Attention is put on the influence of 114 418 texture on the abnormal growth of Brass and Goss grains. Results show that, at initial stage of secondary recrystallization, 114 418 grains in the surface region of sheets possess obvious growth advantage than the other oriented grains. If these grains in the surface region grew to the central layer of sheet and swallowed the nucleus of secondary recrystallization, abnormal growth could not occur. In contrast, reinforcing the inhibitors at surface region of sheet by nitriding treatment will avoid the excessive growth of surface grains and therefore improve magnetic properties of steel significantly. The {114}<418> grains are adverse to the abnormal growth of Brass-oriented and scattered Goss grains in way of island grains, but their effect on the abnormal growth of Goss grains is weaker.

Key words114 418 texture    thin-gauged grain-oriented steel    abnormal growth    inhibitor
    
基金资助:* 国家高技术研究发展计划资助项目2012AA03A505
图1  冷轧板的EBSD取向成像图
图2  初次再结晶后样品的EBSD取向成像图
图3  初次再结晶样品中{114}<418>和{111}<112>织构的晶粒尺寸分布图
图4  高温退火时未渗氮样品在不同温度下的EBSD取向成像图
图5  样品在不同渗氮时间下二次再结晶后的宏观组织
图6  高温退火过程中渗氮60 s的样品加热到1010℃时的EBSD取向成像图
图7  分布在黄铜取向晶粒内部不同位置的{114}<418>岛晶与黄铜取向晶粒取向差的差异
[1] Goss N P. US Pat, 1965559, 1934
[2] Littmann M F, Heek J E. US Pat, 2599340, 1952
[3] Littmann M F. J Appl Phys, 1967; 38: 1104
[4] Park H K, Park C S, Na T W, Han C H, Hwang N M. Mater Trans JIM, 2012; 53: 658
[5] Yoshitomi Y, Ushigami Y, Harase J, Nakayama T, Masui H, Takahashi N. Mater Sci Forum, 1993; 113-115: 715
[6] Park J Y, Szpunar J A. Mater Sci Forum, 2002; 408-412: 821
[7] Hayakawa Y, Kurosawa M. Acta Mater, 2002; 50: 4527
[8] Nakashima S, Takashima K, Harase J. ISIJ Int, 1991; 31: 1013
[9] Yoshitomi Y, Masui H, Harase J, Takahashi N. Mater Trans JIM, 1995; 36: 1234
[10] Park J Y, Han K S, Woo J S, Chang S K, Rajmohan N, Szpunar J A. Acta Mater, 2002; 50: 1825
[11] Harase J, Shimizu R. J Magn Magn Mater, 2000; 215-216: 89
[12] Chang S K. Mater Sci Eng, 2007; A452-453: 93
[13] Matsuo M. ISIJ Int, 1989; 29: 809
[14] Yan M Q, Qian H, Yang P, Mao W M, Jian Q W, Jin W X. J Mater Sci Technol, 2011; 27: 1065
[15] Kumano T, Haratani T, Ushigami Y. ISIJ Int, 2003; 43: 736
[16] Shimazu T, Arai S, Sakai T, Tsubakino H. Tetsu Hagané, 2002; 88: 49 (岛津 高英, 新井 聪, 酒井 知彦, 椿野 晴繁. 铁と钢, 2002; 88: 49)
[17] Yan M Q, Qian H, Yang P, Song H J, Shao Y Y, Mao W M. Acta Metall Sin, 2012; 48: 16 (颜孟奇, 钱 浩, 杨 平, 宋惠军, 邵缓缓, 毛卫民. 金属学报, 2012; 48: 16)
[18] Gobernado P, Petrov R, Ruiz D, Leunis E, Kestens L A I. Adv Eng Mater, 2010; 12: 1077
[19] Lin P, Palumbo G, Harase J, Aust K T. Acta Mater, 1996; 44: 4677
[20] Oyarzábal M, Martínez-de-Guerenu A, Gutiérrez I. Mater Sci Eng, 2008; A485: 200
[21] Gobernado P, Petrov R H, Kestens L A I. Scr Mater, 2012; 66: 623
[22] Gobernado P, Petrov R H, Moerman J, Barbatti C, Kestens L A I. Mater Sci Forum, 2012; 702-703: 790
[23] Quadir M Z, Duggan B J. Acta Mater, 2004; 52: 4011
[24] Toge T, Muraki M, Komatsubara M, Obara T. ISIJ Int, 1998; 38: 524
[25] Nakamura S, Homma H. Mater Sci Forum, 2004; 467-470: 159
[26] Homma H, Nakamura S, Yoshinaga N. Mater Sci Forum, 2004; 467-470: 269
[27] Zhan N, Yang P, Mao W M. Acta Metall Sin, 2012; 48: 782 (张 宁, 杨 平, 毛卫民. 金属学报, 2012; 48: 782)
[28] Kumano T, Haratani T, Ushigami Y. ISIJ Int, 2003; 48: 400
[29] Rajmohan N, Szpunar J A. Scr Mater, 2001; 44: 2387
[1] 何承绪,杨富尧,严国春,孟利,马光,陈新,毛卫民. 常化处理对薄规格取向硅钢织构的影响*[J]. 金属学报, 2016, 52(9): 1063-1069.
[2] 赵宇;何忠治;朱静;翁宇庆;吴宝榕. Sn对高磁感取向硅钢抑制剂强度的贡献[J]. 金属学报, 1993, 29(11): 18-21.