在Na_2S-NaOH浸出液中电沉积Sb时的电化学行为

金属学报

1982, Vol. 18

Issue (3): 378-386

论文

本期目录 | 过刊浏览

在Na_2S-NaOH浸出液中电沉积Sb时的电化学行为

蒋汉瀛;舒余德;赵瑞荣;龚竹青;杨松青

中南矿冶学院;中南矿冶学院;中南矿冶学院;中南矿冶学院;中南矿冶学院

THE ELECTROCHEMICAL BEHAVIOUR OF Sb ELECTROWINNING IN Na_2S-NaOH SOLUTION

Jiang Hanying; Shu Yude; Zhao Ruirong; Gong Zhuqing; Yang Songqing (Central South Institute of Mining and Metallurgy; Changsha)

引用本文:

蒋汉瀛;舒余德;赵瑞荣;龚竹青;杨松青. 在Na_2S-NaOH浸出液中电沉积Sb时的电化学行为[J]. 金属学报, 1982, 18(3): 378-386.
, , , , . THE ELECTROCHEMICAL BEHAVIOUR OF Sb ELECTROWINNING IN Na_2S-NaOH SOLUTION[J]. Acta Metall Sin, 1982, 18(3): 378-386.

全文: PDF(707 KB)

摘要: 本文是湿法炼Sb的物理化学研究中的一部分。当用Na_2S-NaOH溶液浸出复杂的Pb-Sb精矿时,Sb以SbS_3~(3-)离子形态进入溶液。精矿中的Sn和As部分溶解,而Pb则留在残渣中与Sb分离,SbS_3~(3-)离子与空气接触时,部分氧化成SbS_4~(3-)离子。用稳态法测定了极化曲线,确定了在硫化碱溶液中Sb(Ⅲ).Sn(Ⅳ),As(Ⅲ),Sb(Ⅴ)和H~+离子的放电电位。其相应数值如下:-0.92,-1.04,-0.81,-0.68和-1.12V。这些数值分别用纯化学试剂配制的溶液和工业电解液进行了比较测定,并用热力学计算结果进行核对。Sb(Ⅴ)的放电电位还通过计时电位法核对。将所得极化曲线进行浓差极化修正后获得了Tafel直线,由此计算出有关的电极动力学参数。应用计时电位法,探讨了SbS_3~(3-)和SbS_4~(3-)离子的阴极放电机理。结果表明:SbS_3~(3-)离子放电前经历一个前置转化步骤,即: SbS_3~(3)→SbS~++2S~(2-) (1)生成的中间产物SbS~+按下列反应 SbS~++3e→Sb+S~(2-) (2)还原为金属Sb。 SbS_4~(3-)离子在阴极上放电过程分两步进行,首先,SbS_4~(3-)离子按下式还原为SbS_3~(3-)离子, SbS_4~(3-)+2e→SbS_3~(3-)+S~(2-) (3)生成的中间产物SbS_3~(3-)离子再按反应(1)和(2)式还原为金属Sb。

Abstract：By determining the polarization cureve, the discharge potentials of Sb (Ⅲ), Sn (Ⅳ), As (Ⅲ) and H~+ ions were obtain edas -0.92, -1.04, -0.81 and -1.12V respectively, which were checked with the thermodynamic calculation. Their dynamic parameters were estimated by the Tafel lines which resulted after modification of their concentration polarization. At 50℃, the rate constant was found to be 1.54×10~(-4) cm/s, the exchange current density 10~(-2) A/cm~2 and the activation energy 9100 cal/mole.The cathodic discharge mechanism of SbS_3~(3-) and SbS_4~(3-) has been investigated with the help of the chronopotentiometric method. It was shown that before charge transfer, the SbS_3~(3-) ions should be subjected to a prior chemical reaction, i. e. SbS_3~(3-)=SbS~++2S~(2-). The SbS~+ ions formed are then reduced to metallic Sb at the cathode. The discharge of SbS_4~(3-) ions at the cathode takes place in two steps: First, SbS_4~(3-) ions are directly discharged into SbS_3~(3-) and then further reduced into metallic Sb.

收稿日期: 1982-03-18

	服务

	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	蒋汉瀛
	舒余德
	赵瑞荣
	龚竹青
	杨松青
44.8K

链接本文:

https://www.ams.org.cn/CN/ 或 https://www.ams.org.cn/CN/Y1982/V18/I3/378

1 #12
2 Baibordop, P. P., U. S. S. R. Pat. No. 396 396, 1973． (CA 81:28092c).
3 #12
4 蒋汉瀛;赵瑞荣,中南矿冶学院学报,(1978) ,№.4,66．
5 杨松青;龚竹青,中南矿冶学院学报,(1980) ,№.3,62．
6 舒余德,中南矿冶学院学报,(1980) ,№.3,53．
7 蒋汉瀛,有色金属(冶炼部分)(1981) ,№.2,23．
8 清华大学编,晶体管电路(上册),科学出版社,(1973) .p.394．
9 #12
10 #12
11 #12
12 #12
13 #12
14 物理化学数据简明手册,周振华译(第三版)上海科学出版社,1964,p.100．
15 (1975) , No. 1, 54．
16 #12
17 Delahay, P.; Berzins, T., J. Am. Chem. Soc., 75 (1953) , 2486．
18 查全性,电极过程动力学导论,科学出版社,1976． p.327．
19 Hampel, C. A., The Encyclopedia of Electrochemistry, Chapman & Hall, London, 1964, p. 422．

No related articles found!

Viewed

Full text

Abstract

Cited

Shared

Discussed