低温高应变量衬板控轧高固溶Al-Mg合金高强塑性与高热稳定性机制
收稿日期: 2022-05-12
修回日期: 2022-11-18
网络出版日期: 2022-12-06
基金资助
国家自然科学基金项目(51922048);国家自然科学基金项目(51625402);国家自然科学基金项目(51790483)
Enhanced Mechanical Properties and Thermal Stability Mechanism of a High Solid Solution Al-Mg Alloy Processed by Cryogenic High-Reduction Hard-Plate Rolling
Received date: 2022-05-12
Revised date: 2022-11-18
Online published: 2022-12-06
Supported by
National Natural Science Foundation of China(51922048);National Natural Science Foundation of China(51625402);National Natural Science Foundation of China(51790483)
通过大变形技术制备的高强Al-Mg合金具有广阔应用前景,但其塑性低和高温稳定性差的缺点严重限制其进一步发展。本工作采用低温高应变量衬板控轧(cryogenic high-reduction hard-plate rolling,CHR-HPR)制备了兼具高强塑性(抗拉强度约597 MPa、延伸率约7.7%)和高热稳定性的高固溶Mg含量Al-9Mg合金。利用EBSD、TEM、硬度测量和拉伸实验等方法系统研究了Mg含量对CHR-HPR Al-Mg合金微观组织和力学性能的影响。结果表明:CHR-HPR Al-9Mg合金中高含量固溶Mg原子与低温变形促进合金中形成了高密度位错及小角晶界,显著提高合金的屈服强度;高含量固溶Mg原子与可动位错交互作用引起的动态应变时效导致合金加工硬化能力提高,进一步提高了合金的抗拉强度和塑性。此外,在再结晶退火过程中,高含量固溶Mg原子有效地抑制位错滑移、钉扎晶界,延缓回复与再结晶的发生。因此,CHR-HPR Al-Mg合金热稳定性随固溶Mg含量增加而显著提高,其中CHR-HPR Al-9Mg合金再结晶温度达到400℃。
田滕 , 查敏 , 殷皓亮 , 花珍铭 , 贾海龙 , 王慧远 . 低温高应变量衬板控轧高固溶Al-Mg合金高强塑性与高热稳定性机制[J]. 金属学报, 2024 , 60(4) : 473 -484 . DOI: 10.11900/0412.1961.2022.00239
Al-Mg series alloys are highly desirable for structural applications, owing to their high specific strength, good formability, and excellent corrosion resistance. However, high-strength Al-Mg alloys prepared via severe plastic deformation generally exhibit poor thermal stability, which is caused by the high-density grain boundaries (GBs). Achieving simultaneous high strength and thermal stability in binary Al-Mg alloys remains a challenge. In this study, Al-9Mg alloys with a combination of high strength (~597 MPa), decent elongation (~7.7%), and enhanced thermal stability were developed via cryogenic high-reduction hard-plate rolling (CHR-HPR). The effects of solute Mg content on the microstructure evolution and mechanical properties of CHR-HPR Al-Mg alloys were systematically investigated using EBSD, TEM, microhardness measurements, and tensile tests. The high yield strength is derived from high-density dislocations and low-angle GBs promoted via the high content of solute Mg atoms and low deformation temperature. In addition to the positive roles of Mg atoms and low deformation temperature on work-hardening ability, the simultaneous improvement in the ultimate tensile strength and ductility of CHR-HPR Al-Mg alloys with increasing solute Mg content is partially attributed to the enhanced work hardening induced via the dynamic strain aging. Furthermore, the recrystallization temperature of the CHR-HPR Al-Mg alloys gradually increased with increasing solute Mg content, and the recrystallization temperature of CHR-HPR Al-9Mg could reach 400oC. The enhanced thermal stability of CHR-HPR Al-9Mg alloy is due to the high content Mg solute atoms, which strongly retard recovery and recrystallization by dragging dislocations and pinning GBs.
| 1 | Zha M, Zhang H M, Jia H L, et al. Prominent role of multi-scale microstructural heterogeneities on superplastic deformation of a high solid solution Al-7Mg alloy[J]. Int. J. Plast., 2021, 146: 103108 |
| 2 | Tang Y P, Goto W, Hirosawa S, et al. Concurrent strengthening of ultrafine-grained age-hardenable Al-Mg alloy by means of high-pressure torsion and spinodal decomposition[J]. Acta Mater., 2017, 131: 57 |
| 3 | Yuan T, Zhao X H, Jiang X Q, et al. Mechanism of grain refinement of pulse current assisted plasma arc welded Al-Mg alloy[J]. Acta Metall. Sin., 2024, 60: 323 |
| 袁 涛, 赵晓虎, 蒋晓青 等. 脉冲电流辅助等离子弧焊Al-Mg合金晶粒细化机理[J]. 金属学报, 2024, 60: 323 | |
| 4 | Zha M, Zhang H M, Meng X T, et al. Stabilizing a severely deformed Al-7Mg alloy with a multimodal grain structure via Mg solute segregation[J]. J. Mater. Sci. Technol., 2021, 89: 141 |
| 5 | Jang D H, Park Y B, Kim W J. Significant strengthening in superlight Al-Mg alloy with an exceptionally large amount of Mg (13?wt%) after cold rolling[J]. Mater. Sci. Eng., 2019, A744: 36 |
| 6 | Morishige T, Hirata T, Uesugi T, et al. Effect of Mg content on the minimum grain size of Al-Mg alloys obtained by friction stir processing[J]. Scr. Mater., 2011, 64: 355 |
| 7 | Sun J X, Yang K, Wang Q Y, et al. Microstructure and mechanical properties of 5356 aluminum alloy fabricated by TIG arc additive manufacturing[J]. Acta Metall. Sin., 2021, 57: 665 |
| 孙佳孝, 杨 可, 王秋雨 等. 5356铝合金TIG电弧增材制造组织与力学性能[J]. 金属学报, 2021, 57: 665 | |
| 8 | Zha M, Li Y J, Mathiesen R H, et al. Microstructure evolution and mechanical behavior of a binary Al-7Mg alloy processed by equal-channel angular pressing[J]. Acta Mater., 2015, 84: 42 |
| 9 | Liu Y, Liu M P, Chen X F, et al. Effect of Mg on microstructure and mechanical properties of Al-Mg alloys produced by high pressure torsion[J]. Scr. Mater., 2019, 159: 137 |
| 10 | Ruppert M, Schunk C, Hausmann D, et al. Global and local strain rate sensitivity of bimodal Al-laminates produced by accumulative roll bonding[J]. Acta Mater., 2016, 103: 643 |
| 11 | Luo X, Feng Z Q, Yu T B, et al. Transitions in mechanical behavior and in deformation mechanisms enhance the strength and ductility of Mg-3Gd[J]. Acta Mater., 2020, 183: 398 |
| 12 | Konkova T, Mironov S, Korznikov A, et al. Microstructural response of pure copper to cryogenic rolling[J]. Acta Mater., 2010, 58: 5262 |
| 13 | Wang Y M, Chen M W, Zhou F H, et al. High tensile ductility in a nanostructured metal[J]. Nature, 2002, 419: 912 |
| 14 | Zha M, Li Y J, Mathiesen R H, et al. High ductility bulk nanostructured Al-Mg binary alloy processed by equal channel angular pressing and inter-pass annealing[J]. Scr. Mater., 2015, 105: 22 |
| 15 | Krymskiy S, Sitdikov O, Avtokratova E, et al. 2024 aluminum alloy ultrahigh-strength sheet due to two-level nanostructuring under cryorolling and heat treatment[J]. Trans. Nonferrous Met. Soc. China, 2020, 30: 14 |
| 16 | Kumar V, Kumar D. Investigation of tensile behaviour of cryorolled and room temperature rolled 6082 Al alloy[J]. Mater. Sci. Eng., 2017, A691: 211 |
| 17 | Zhang H M, Zha M, Jia H L, et al. Influences of the Al3Sc particle content on the evolution of bimodal grain structure and mechanical properties of Al-Mg-Sc alloys processed by hard-plate rolling[J]. Mater. Sci. Eng., 2021, A802: 140451 |
| 18 | Zha M, Meng X T, Zhang H M, et al. High strength and ductile high solid solution Al-Mg alloy processed by a novel hard-plate rolling route[J]. J. Alloys Compd., 2017, 728: 872 |
| 19 | Zha M, Liang J W, Xing H, et al. Spheroiding and refining of coarse CaMgSn phase in Mg-Al-Sn-Ca alloys for simultaneously improved strength and ductility via sub-rapid solidification and controlled rolling[J]. Mater. Sci. Eng., 2022, A834: 142598 |
| 20 | Li Y K, Zha M, Jia H L, et al. Tailoring bimodal grain structure of Mg-9Al-1Zn alloy for strength-ductility synergy: Co-regulating effect from coarse Al2Y and submicron Mg17Al12 particles[J]. J. Magnes. Alloy., 2021, 9: 1556 |
| 21 | Li Y K, Zha M, Rong J, et al. Effect of large thickness-reduction on microstructure evolution and tensile properties of Mg-9Al-1Zn alloy processed by hard-plate rolling[J]. J. Mater. Sci. Technol., 2021, 88: 215 |
| 22 | Jin Z Z, Zha M, Jia H L, et al. Balancing the strength and ductility of Mg-6Zn-0.2Ca alloy via sub-rapid solidification combined with hard-plate rolling[J]. J. Mater. Sci. Technol., 2021, 81: 219 |
| 23 | Zhang H, Zha M, Tian T, et al. Prominent role of high-volume fraction Mg17Al12 dynamic precipitations on multimodal microstructure formation and strength-ductility synergy of Mg-Al-Zn alloys processed by hard-plate rolling (HPR)[J]. Mater. Sci. Eng., 2021, A808: 140920 |
| 24 | Zhou F, Liao X Z, Zhu Y T, et al. Microstructural evolution during recovery and recrystallization of a nanocrystalline Al-Mg alloy prepared by cryogenic ball milling[J]. Acta Mater., 2003, 51: 2777 |
| 25 | Alyani A, Kazeminezhad M. Annealing behavior of aluminum after low-temperature severe plastic deformation[J]. Mater. Sci. Eng., 2021, A824: 141810 |
| 26 | Dhal A, Panigrahi S K, Shunmugam M S. Insight into the microstructural evolution during cryo-severe plastic deformation and post-deformation annealing of aluminum and its alloys[J]. J. Alloys Compd., 2017, 726: 1205 |
| 27 | Gao Y H, Liu G, Sun J. Recent progress in high-temperature resistant aluminum-based alloys: Microstructural design and precipitation strategy[J]. Acta Metall. Sin., 2021, 57: 129 |
| 高一涵, 刘 刚, 孙 军. 耐热铝基合金研究进展: 微观组织设计与析出策略[J]. 金属学报, 2021, 57: 129 | |
| 28 | Hasegawa H, Komura S, Utsunomiya A, et al. Thermal stability of ultrafine-grained aluminum in the presence of Mg and Zr additions[J]. Mater. Sci. Eng., 1999, A265: 188 |
| 29 | Hayes J S, Keyte R, Prangnell P B. Effect of grain size on tensile behaviour of a submicron grained Al-3wt%-Mg alloy produced by severe deformation[J]. Mater. Sci. Technol., 2000, 16: 1259 |
| 30 | Zha M, Meng X T, Yu Z Y, et al. Enhancing thermal stability of binary Al-Mg alloys by tailoring grain orientations using a high solute Mg content[J]. Metall. Mater. Trans., 2019, 50A: 5264 |
| 31 | Jin S B, Tao N R, Marthinsen K, et al. Deformation of an Al-7Mg alloy with extensive structural micro-segregations during dynamic plastic deformation[J]. Mater. Sci. Eng., 2015, A628: 160 |
| 32 | Han B S, Wei L J, Xu Y J, et al. Effect of pre-deformation on microstructure and mechanical properties of ultra-high strength Al-Zn-Mg-Cu alloy after ageing treatment[J]. Acta Metall. Sin., 2020, 56: 1007 |
| 韩宝帅, 魏立军, 徐严谨 等. 预变形对超高强Al-Zn-Mg-Cu合金时效组织与力学性能的影响[J]. 金属学报, 2020, 56: 1007 | |
| 33 | Kreyca J, Kozeschnik E. State parameter-based constitutive modelling of stress strain curves in Al-Mg solid solutions[J]. Int. J. Plast., 2018, 103: 67 |
| 34 | Fu S H, Cheng T, Zhang Q C, et al. Two mechanisms for the normal and inverse behaviors of the critical strain for the Portevin-Le Chatelier effect[J]. Acta Mater., 2012, 60: 6650 |
| 35 | Jobba M, Mishra R K, Niewczas M. Flow stress and work-hardening behaviour of Al-Mg binary alloys[J]. Int. J. Plast., 2015, 65: 43 |
| 36 | Ma K K, Wen H M, Hu T, et al. Mechanical behavior and strengthening mechanisms in ultrafine grain precipitation-strengthened aluminum alloy[J]. Acta Mater., 2014, 62: 141 |
| 37 | Pan H C, Kang R, Li J R, et al. Mechanistic investigation of a low-alloy Mg-Ca-based extrusion alloy with high strength-ductility synergy[J]. Acta Mater., 2020, 186: 278 |
| 38 | Hansen N. Hall-Petch relation and boundary strengthening[J]. Scr. Mater., 2004, 51: 801 |
| 39 | Valiev R Z, Enikeev N A, Murashkin M Y, et al. On the origin of the extremely high strength of ultrafine-grained Al alloys produced by severe plastic deformation[J]. Scr. Mater., 2010, 63: 949 |
| 40 | Liu G, Zhang P, Yang C, et al. Aluminum alloys: Solute atom clusters and their strengthening[J]. Acta Metall. Sin., 2021, 57: 1484 |
| 刘 刚, 张 鹏, 杨 冲 等. 铝合金中的溶质原子团簇及其强韧化[J]. 金属学报, 2021, 57: 1484 | |
| 41 | Chen Y J, Roven H J, Gireesh S S, et al. Quantitative study of grain refinement in Al-Mg alloy processed by equal channel angular pressing at cryogenic temperature[J]. Mater. Lett., 2011, 65: 3472 |
/
| 〈 |
|
〉 |