论文

AZ31镁合金热变形流动应力预测模型

  • 孙朝阳 ,
  • 栾京东 ,
  • 刘赓 ,
  • 李瑞 ,
  • 张清东
展开
  • 北京科技大学机械工程学院, 北京 100083
孙朝阳, 男, 1976年生, 副教授, 博士

收稿日期: 2011-10-12

  修回日期: 2012-05-08

  网络出版日期: 2012-07-11

基金资助

国家自然科学基金项目50831008和51105029资助

PREDICTED CONSTITUTIVE MODELING OF HOT DEFORMATION FOR AZ31 MAGNESIUM ALLOY

  • XUN Zhao-Yang ,
  • LUAN Jing-Dong ,
  • LIU Geng ,
  • LI Rui ,
  • ZHANG Qing-Dong
Expand
  • School of Mechanical and Engineering, University of Science and Technology Beijing, Beijing 100083

Received date: 2011-10-12

  Revised date: 2012-05-08

  Online published: 2012-07-11

摘要

采用近等温单轴压缩实验获得了AZ31镁合金变形温度为523-723 K, 应变速率为0.01-10 s-1条件下的流动应力, 分析了变形温度和应变速率对流动应力的影响规律. 结果表明, AZ31镁合金变形过程中发生了动态再结晶, 523 K时形成细小组织; 而723 K时动态再结晶和长大的晶粒沿径向拉长. 考虑实验过程塑性变形功和摩擦功引起的温度升高, 在高应变速率条件下采用温度补偿修正了流动应力. 在此基础上, 建立了基于双曲正弦模型的峰值流动应力和统一本构关系, 该模型利用材料参数耦合应变来描述流动应力的应变敏感性, 进一步获得了合金热变形过程中流动应力与变形温度、应变速率和应变的定量关系. 采用该本构关系模型预测流动应力具有较高的精度, 预测值与实测值相关系数为0.976, 平均相对误差为5.07%, 实验条件范围内预测的流动应力与实验值几乎能保持一致.

本文引用格式

孙朝阳 , 栾京东 , 刘赓 , 李瑞 , 张清东 . AZ31镁合金热变形流动应力预测模型[J]. 金属学报, 2012 , 48(7) : 853 -860 . DOI: 10.3724/SP.J.1037.2011.00641

Abstract

The uniaxial compression tests of AZ31 magnesium alloy at different strain rates of 0.01-10 s-1 and different deformation temperatures of 523-723 K were performed by using Gleeble-1500 simulator with a maximum strain of 0.916. The influences of deformation temperature and strain rate on the flow stress were investigated. The fine microstructure is attributed to dynamic recrystallization during compression process at 523 K. The stretched grains of dynamic recrystallization and growth up along radial direction were founded in microscopic observation at 723 K. Considering plasticity deformation and friction induced temperature rise, the flow stress was corrected at high strain rate by using temperature compensation. The peak flow stress and unified constitutive model were established based on hyperbolic sine model. Strain sensitivity of flow stress was studied to describe the coupling of materials parameters on the strain, and then the relationship between deformation temperature, strain rate and strain during hot deformation was obtained. Comparing with experimental results, the correlation coefficient and average relative error of predicted and measured values are 0.976 and 5.07\% respectively, it is proved that the model reflects the real deformation feature of the AZ31 magnesium alloy.

参考文献

[1] Liu Q. Acta Metall Sin, 2010; 46: 1458

(刘庆. 金属学报, 2010; 46: 1458)

[2] Xiao P, Liu T M, Jiang D. J Chongqing Univ (Nat Sci Ed), 2006; 29(11): 81

(肖 盼, 刘天模, 姜丹.重庆大学学报(自然科学版), 2006; 29(11): 81)

[3] Guo Q, Zhang H, Chen Z H, Yan H G, Xia W J, Fu D F. Nat Sci J Xiangtan Univ, 2004; 26: 108

(郭强, 张辉, 陈振华, 严红革, 夏伟军, 傅定发.湘潭大学自然科学学报, 2004; 26: 108)

[4] Carl M, Korzekw A C, Cerreta E, Lopez F. J Miner Met Mater Soc, 2004; 56(11): 31

[5] Takuda H. J Mater Process Technol, 1998; 80/81: 513

[6] Galiyev A, Kaibyshev R, Sakai T. Mater Sci Forum, 2003; 419–422: 419

[7] Barnett M R. J Light Met, 2001; 1: 167

[8] Fan Y G, Wang L Y, Huang G S, Huang G J. J Chongqing Univ (Nat Sci Ed), 2003; 26(2): 9

(范永革, 汪凌云, 黄光胜, 黄光杰.重庆大学学报(自然科学版), 2003; 6(2): 9)

[9] Wang Z T, Zhang S H, Qi G X, Wang F, Li Y J. Chin J Nonferrous Met, 2008; 18: 1977

(王忠堂, 张士宏, 齐广霞, 王芳, 李艳娟.中国有色金属学报, 2008; 18: 1977)

[10] Huang G S, Wang L Y, Huang G J, Lu Z W, Song M J. Met Form Technol, 2004; 22(2): 42

(黄光胜, 汪凌云, 黄光杰, 卢志文, 宋美娟. 金属成形工艺, 2004; 22(2): 42)

[11] Guo Q, Yan H G, Chen Z H, Zhang H. Chin J Nonferrous Met, 2005; 15: 900

(郭 强, 严红革, 陈振华, 张辉. 中国有色金属学报, 2005; 15: 900)

[12] Zhang X H, Cui Z S, Ruan X Y. J Shanghai Jiaotong Univ, 2003; 37: 1874

(张先宏, 崔振山, 阮雪榆. 上海交通大学学报, 2003; 37: 1874)

[13] Yu K, Shi T, Wang R C, Li W X, Wang X Y, Cai Z Y. J Cent South Univ (Sci Technol), 2008; 39: 216

(余琨, 史禔, 王日初, 黎文献, 王晓艳, 蔡志勇. 中南大学学报(自然科学版), 2008; 39: 216)

[14] Sun C Y, Liu J R, Li R, Zhang Q D, Dong J X. Real Met, 2011; 30: 81

[15] Luan N, Li L X, Li G Y, Zhong Z H. Chin J Nonferrous Met, 2007; 17: 1678

(栾娜, 李落星, 李光耀, 钟志华. 中国有色金属学报, 2007; 17: 1678)

[16] Luo Z J, Yang Q, Ji W H. Chin J Nonferrous Met, 2000; 10: 804

(罗子健, 杨旗, 姬婉华. 中国有色金属学报, 2000; 10: 804)

[17] Zhang W H, Zhang S H. Acta Metall Sin, 2006; 42: 1036

(张伟红, 张士宏. 金属学报, 2006; 42: 1036)

[18] Wang Z X, Liu X F, Xie J X. Acta Metall Sin, 2008; 44: 1378

(王智祥, 刘雪峰, 谢建新. 金属学报, 2008; 44: 1378)

[19] Sellars C M, McTegart W J. Acta Metall, 1966; 14: 1136

[20] Mcqueen H J, Ryan N D. Mater Sci Eng, 2002; A322: 43

[21] Gronostajski Z J. J Mater Process Technol, 1998; 78: 84

[22] Whittenberger J D. Mater Sci Eng, 1986; 77: 103

[23] Zener C, Hollomon H. J Appl Phys, 1944; 15: 22

[24] Sun C Y, Liu J R, Li R, Zhang Q D. Acta Metall Sin, 2011; 47: 191

(孙朝阳, 刘金榕, 李瑞, 张清东. 金属学报, 2011; 47: 191)

[25] Ismael A M, Ahmed H, Johannes R. Mater Sci Eng, 2009; A504: 40
文章导航

/