Please wait a minute...
金属学报  2004, Vol. 40 Issue (5): 527-530     
  论文 本期目录 | 过刊浏览 |
Cr含量对TiMn1.2-xCrxV0.25Fe0.05合金吸/放氢性能的影响
余学斌; 陈金舟; 吴铸; 夏保佳
中国科学院上海微系统与信息技术研究所; 上海 200050
Effect of Cr Content on the Sorption Performance of TiMn1.2-xCrxV0.25Fe0.05 Alloys
YU Xuebin; CHEN Jinzhou; WU Zhu; XIA Baojia
Shanghai Institute of Microsystem and Information Technology; The Chinese Academy of Sciences; Shanghai 200050
引用本文:

余学斌; 陈金舟; 吴铸; 夏保佳 . Cr含量对TiMn1.2-xCrxV0.25Fe0.05合金吸/放氢性能的影响[J]. 金属学报, 2004, 40(5): 527-530 .
, , , . Effect of Cr Content on the Sorption Performance of TiMn1.2-xCrxV0.25Fe0.05 Alloys[J]. Acta Metall Sin, 2004, 40(5): 527-530 .

全文: PDF(2253 KB)  
摘要: 对名义成分为TiMn1.2-xCrxV0.25Fe0.05(x=0.0, 0.1, 0.2, 0.3, 0.4) 合金的储氢性能进行了研究. 结果表明, 合金的晶格常数和晶胞体积随Cr含量的增加而增大; 随着Cr含量的增加, 合金的吸/放氢平台压力和滞后效应减小. 随着Cr含量的变化, TiMn1.2-xCrxV0.25Fe0.05合金112峰半高宽(FWHM)和晶格常数c/a比率的变化与该合金吸/放氢平台斜率的变化一致, 表明合金的平台斜率与合金的晶格畸变关系密切. TiMn1.0Cr0.2V0.25Fe0.05合金具有较大的储氢量、低的平台压力、小的滞后和斜率, 适于作为质子交换膜燃料电池供氢源的储氢瓶应用.
关键词 TiMn1.2-xCrxV0.25Fe0.05合金储氢量     
Abstract:The hydrogen absorption-desorption characteristics of TiMn1.2-xCrxV0.25Fe0.05(x=0.0, 0.1, 0.2, 0.3, 0.4) alloys as a hydrogen storage tank were investigated. XRD results show that the lattice constants and the unit cell volume increase with increasing Cr content. The PCT results exhibit that the hydrogen sorption plateau pressure and hysteresis decrease with increasing Cr content. The change in the full width half maximum (FWHM) and c/a ratio with the change in the degree of slope present the same trend with Cr concentration, which implies that the slope behaviors in TiMn1.2-xCrxV0.25Fe0.05 system are closely correlated with the strain energy of interstitial site. In all cases, the TiMn1.0Cr0.2V0.25Fe0.05 alloy exhibits a larger hydrogen capacity, lower plateau pressure, and smaller hysteresis and slope properties, which can satisfy the demand of hydrogen storage tanks for proton exchange membrane fuel cell.
Key wordsalloy    hydrogen storage capacity   
收稿日期: 2003-05-08     
ZTFLH:  TG139.7  
[1] Mani N, Sivakumar R, Ramaprabhu S. J Alloys Compd, 2002; 337:148
[2] Kim Jin-Ho, Lee Ho, Lee Paul S. J Alloys Compd, 2003; 348:293
[3] Tanaka K, Sowa M, Kita Y, Kubota T, Tanaka N. J Alloys Cornpd, 2002; 330-332:732
[4] Lee Sang-Min, Yu Ji Sang, Lee Ho, Jang Kulk-Jin, Lee Jai-Young. J Alloys Compd, 1999; 293-295:601
[5] Mitrokhin S V, Bezugtaya T N, Verbetaky V N. J Alloys Compd, 2002; 330-332:146
[6] Park Jeong-Gun, Jang Hwan-Young, Han Sang-Cheol, Lee Paul S, Lee Jai-Young. J Alloys Compd, 2001; 325: 293-298
[7] Hong C M, Hao D G, Lin Q Z. d Less-Common Met, 1991; 172-174:1044
[8] Mitrokhin S V, Verbetsky V N. J Alloys Cornpd, 1997; 253-254:201
[9] Hagstrom M T, Klyamkin S N, Lund P D. J Alloys Compd, 1999; 293-295:67
[10] Guther V, Otto A. J Alloys Cornpd, 1999; 293-295:889
[11] Yu X B, Wu Z, Huang T Z. Trans Nonferrous Met Soc Chin, 2003; 13:1116(徐学斌,吴铸,黄太仲.中国有色金属学报,2003;13:1116)
[12] Lundin C E, Lynch F E, Magee C B. J Less-Common Met, 1977; 56:19
[13] Ivey D G, Northwood D O. J Mater Sci, 1981; 18:321
[14] Park Jong-Man, Lee Jai-Young. J Less-Common Met, 1991; 167:245
[15] Magee C B, Lju J, Lundin C E. J Less-Common Met, 1981; 78:119
[1] 马坪, 吴二冬, 李武会, 孙凯, 陈东风. Ti0.7Zr0.3(Cr1-xVx)2合金的结构和贮氢性能*[J]. 金属学报, 2014, 50(4): 454-462.
[2] 黄火根 贾建平 李嵘. Pd替代对Ti-Zr-Ni准晶合金结构的影响[J]. 金属学报, 2009, 45(10): 1272-1276.
[3] 方方; 张晶; 朱健; 陈国荣; 孙大林 . NaAlH4分解后的加氢过程研究[J]. 金属学报, 2007, 42(1): 96-98 .
[4] 汪洋; 张琰; 王新华; 陈长聘 . Ti-Cr基合金的储氢性能及晶体结构[J]. 金属学报, 2006, 42(6): 641-646 .
[5] 陈妮; 李锐; 朱云峰; 刘永锋; 潘洪革 . Ti--V基多相贮氢电极合金的电化学吸放氢机理研究[J]. 金属学报, 2004, 40(11): 1200-1204 .
[6] 袁志庆; 吕光烈; 曾跃武; 魏范松; 雷永泉 . La(Ni, Sn)(5+x)(x=0.1---0.4)三元贮氢合金的晶体结构及微结构研究[J]. 金属学报, 2004, 40(8): 805-809 .
[7] 王辉; 欧阳柳章; 曾美琴; 朱敏 . 热蒸发法制备Mg和Mg-Ni薄膜及其氢化性能[J]. 金属学报, 2004, 40(5): 531-536 .
[8] 朱光明; 雷永泉; 陈立新 . 二元稀土系AB5型贮氢电极合金的放电容量与晶胞体积和4f电子的关系[J]. 金属学报, 2003, 39(7): 781-784 .
[9] 刘永锋; 潘洪革; 高明霞; 朱云峰; 葛红卫; 李寿权; 雷永泉 . 稀土镁基贮氢电极合金的结构与电化学性能研究[J]. 金属学报, 2003, 39(6): 666-672 .
[10] 花均社; 孙玉珍; 王文皓; 孙文生; 才庆魁; 胡壮麒 . 次亚磷酸钠对贮氢合金活化性能的影响[J]. 金属学报, 2001, 37(5): 522-526 .
[11] 马建新; 潘洪革; 朱云峰; 李寿权; 陈长聘 . 一种改善贮氢电极合金电化学性能的新方法[J]. 金属学报, 2001, 37(1): 57-60 .
[12] 朱光明; 陈立新; 雷永泉; 王启东; 尤金跨; 林祖赓 . RE(Ni,Co,Mn,Ti)5合金(RE=La,Ce,Pr,Nd) 的单胞体积对电化学性能的影响[J]. 金属学报, 2001, 37(1): 61-66 .
[13] 郭进; 李卫 . RENi5及其氢化物电子结构与吸氢性能的相关性研究[J]. 金属学报, 2000, 36(11): 1149-1152 .
[14] 王平; 张海峰 . 反应球磨中Mg的直接氢化[J]. 金属学报, 2000, 36(10): 1118-1120 .
[15] 任可; 雷永泉 . Zr替代稀土对RE(NiCoMnTi)5贮氢合金相结构和性能的影响[J]. 金属学报, 2000, 36(8): 854-858 .