Please wait a minute...
金属学报  2013, Vol. 49 Issue (6): 658-666    DOI: 10.3724/SP.J.1037.2012.00684
  论文 本期目录 | 过刊浏览 |
预疲劳变形对粗晶纯Al单向拉伸行为的影响
颜莹1),卢蒙1),李小武1,2)
1) 东北大学理学院材料物理与化学研究所, 沈阳 110819
2) 东北大学材料各向异性与织构教育部重点实验室, 沈阳 110819
EFFECTS OF PRE-FATIGUE DEFORMATION ON THE  UNIAXIAL TENSILE BEHAVIOR OF COARSEGRAINED PURE Al
YAN Ying1), LU Meng1), LI Xiaowu1,2)
1) Institute of Materials Physics and Chemistry, College of Sciences, Northeastern University, Shenyang 110819
2) Key Laboratory for Anisotropy and Texture of Materials, Ministry of Education, Northeastern University, Shenyang 110819
引用本文:

颜莹,卢蒙,李小武. 预疲劳变形对粗晶纯Al单向拉伸行为的影响[J]. 金属学报, 2013, 49(6): 658-666.
YAN Ying, LU Meng, LI Xiaowu. EFFECTS OF PRE-FATIGUE DEFORMATION ON THE  UNIAXIAL TENSILE BEHAVIOR OF COARSEGRAINED PURE Al[J]. Acta Metall Sin, 2013, 49(6): 658-666.

全文: PDF(5734 KB)  
摘要: 

在恒应力幅下对粗晶纯Al进行不同疲劳寿命分数D(D=2%-75%)的预疲劳变形,研究预疲劳变形对其单向拉伸行为、断口表面变形特征和位错组态的影响.结果表明, 随着D的提高, 粗晶纯Al的表面挤出和侵入现象加重,晶内的不均匀变形程度增大, 导致沿滑移带和晶界萌生微裂纹和微孔洞以及随后的连接,当D高达75%时, 三叉晶界节点处产生较长的沿晶裂纹.疲劳位错组态由退火时松散的胞状结构演变成规整的胞状结构和亚晶,但亚晶尺寸并未发生明显变化. 预疲劳的粗晶纯Al单向拉伸后, 其屈服强度明显提高,但随D的提高, 屈服强度变化不大, 抗拉强度呈现先降低再升高和最终急剧下降的趋势,但其加工硬化能力较弱. 单向拉伸断口由纤维区和剪切唇区组成, 纤维区韧窝的数量随D的提高而增多,尺寸减小, 当D=50%时, 韧窝数量下降, 尺寸增大, 断口呈现撕裂特征.单向拉伸后的亚结构主要为亚晶和亚内的位错胞状结构, 随着D的提高,亚晶先减小后增大, 亚晶的细化和亚晶内位错胞状结构的形成使预疲劳后的粗晶纯Al具有较高的最大均匀延伸率.

关键词 粗晶纯Al预疲劳变形单向拉伸断口位错结构    
Abstract

The coarse-grained pure Al was first pre-fatigued to different fatigue life fractions D(D=2%-75 {%}) at a constant stress amplitude, and then the effect of pre-fatigue deformation on its uniaxial tensile behavior, fracture surface deformation features and dislocation structures were investigated. The results show that with increasing D, the extrusion/intrusion phenomenon on the surfaces of the pre-fatigued coarse-grained pure Al becomes more serious, and the non-uniform deformation in grain interiors is also enhanced, leading to the nucleation of micro-cracks and micro-voids along slip bands (SBs) or at grain boundaries (GBs) as well as their subsequent propagation. As D is as high as 75%, the longer intergranular cracks are produced at triple grain boundary nodes. With increasing D, the fatigue dislocation structures transform from loose cellular structures under annealing state into regular cellular structures and sub-grains, but the size of sub-grains nearly does not change. After the pre-fatigued coarse-grained pure Al specimens were subjected to the uniaxial tension, the yield strengthσYS obviously increases, but the change inσYS is not so obvious as D increases. Meanwhile, the ultimate tensile strengthσUTS first decreases and then increases, and finally sharply re-decreases. However, the pre-fatigued coarse-grained pure Al has poor ability to work hardening. The tensile fracture surface consists of fibrous and shear lip zones, and the number of dimples in fibrous zones increases and the size reduces with increasing D; as D reaches 50%, the number of dimples re-reduces and the size raises, and the fracture surface exhibits tearing characteristics. The sub-structures after the uniaxial tension are mainly composed of sub-grains and cellular dislocation structures inside sub-grains, and with increasing D, the size of sub-grains first reduces and then increases. The formation of fine sub-grains and cellular dislocation structures inside sub-grains results in the fact that the pre-fatigued coarse-grained pure Al has higher maximum uniform percent elongation.

Key wordscoarse-grained pure Al    pre-fatigue deformation    uniaxial tension    fracture surface    dislocation structure
收稿日期: 2012-11-15     
基金资助:

国家自然科学基金项目51271054, 51071041和51231002, 高等学校博士学科点专项科研基金博导类项目20110042110017及中央高校基本科研业务项目N110105001和N120505001资助

作者简介: 颜莹, 女, 1966年生, 副教授, 博士

[1] Torres M A S, Voorwald H J C.  Int J Fatigue, 2002; 24: 877

[2] Williams J J, Deng X, Chawla N.  Int J Fatigue, 2007; 29: 1978
[3] Al-Rubaie K S, Del Grande M A, Travessa D N, Cardoso K R.  Mater Sci Eng, 2007; A464: 141
[4] Niendorf T, Lotze C, Canadinc D, Frehn A, Maier H J.  Mater Sci Eng, 2009; A499: 518
[5] Mocilnik V, Gubeljak N, Predan J, Flasker J.  Eng Fract Mech, 2010; 77: 3132
[6] Valiev R Z, Langdon T G.  Prog  Mater Sci, 2006; 51: 881
[7] Estrin Y, Vinogradov A.  Int J Fatigue, 2010; 32: 898
 [8] Galan Lopez J, Verleysen P, De Baere I, Degrieck J.  Procedia Eng,2011; 10: 1961
[9] Froustey C, Lataillade J L.  Mater Sci Eng, 2009; A500: 155
[10] Sanchez-Santana U, Rubio-Gonzalez C, Mesmacque G, Amrouche A. Int J Fatigue, 2009; 31: 1928
[11] Sanchez-Santana U, Rubio-Gonz alez C, Mesmacque G, Amrouche A,Decoopman X.  Int J Fatigue, 2008; 30: 1708
[12] Sanchez-Santana U, Rubio-Gonzalez C, Mesmacque G, Amrouche A,Decoopman X.  Mater Sci Eng, 2008; A497: 51
[13] Ye D Y, Xu Y D, Xiao L, Cha H B.  Mater Sci Eng, 2010; A527: 4092
[14] Verleysen P, Vanduyslager P, Van Slycken J, Vermeulen M, Degrieck J.  J Phy IV,2006; 134: 1307
[15] Li X W, Wang X M, Guo W W, Qi C J, Yan Y.  Metall Mater Trans, 2013; 44A: 1631
[16] Xia Y B, Wang Z G.  Acta Metall Sin, 1992; 28: A51
 (夏月波, 王中光. 金属学报, 1992; 28: A51)
[17] Liu G D, Zhu Z G, Wang J.  Acta Metall Sin, 1996; 5: 510
 (刘国东, 朱振刚, 王静. 金属学报, 1996; 5: 510)
[18] Videm M, Ryum N.  Mater Sci Eng, 1996; A219: 1
[19] Giese A, Estrin Y.  Scr Metall, 1993; 28: 803
[20] Fujii T, Sawatari N, Onaka S, Kato M.  Mater Sci Eng, 2004; A387--389: 486
[21] Vorren O, Ryum N.  Acta Metall, 1987; 35: 855
[22] Videm M, Ryum N.  Mater Sci Eng, 1996; A219: 11
[23] Xia Y B, Wang Z G, Ai S H.  Acta Metall Sin, 1982; 18: 606
 (夏月波, 王中光, 艾素华. 金属学报, 1982: 18: 606)
[24] Wang H, Xu Y L, Sun Q Y, Xiao L, Sun J.  Acta Metall Sin, 2009; 45: 434
 (王航, 徐燕灵, 孙巧艳, 肖林, 孙军. 金属学报, 2009; 45: 434)
[25] Li C.  Metallography Theory. Harbin: Harbin Industry University Press, 1996: 274
 (李超. 金属学原理. 哈尔滨: 哈尔滨工业大学出版社, 1996: 274)
[1] 韩冬, 张炎杰, 李小武. 短程有序对高层错能Cu-Mn合金拉-拉疲劳变形行为及损伤机制的影响[J]. 金属学报, 2022, 58(9): 1208-1220.
[2] 李民, 李昊泽, 王继杰, 马颖澈, 刘奎. 稀土Ce对薄带连铸无取向6.5%Si钢组织、高温拉伸性能和断裂模式的影响[J]. 金属学报, 2022, 58(5): 637-648.
[3] 金辰日, 杨素媛, 邓学元, 王扬卫, 程兴旺. 纳米晶化对锆基非晶合金动态压缩性能的影响[J]. 金属学报, 2019, 55(12): 1561-1568.
[4] 李敏, 刘静, 姜庆伟. 退火温度对ARB-Cu室温拉伸断裂行为的影响[J]. 金属学报, 2017, 53(8): 1001-1010.
[5] 李飞,张华煜,何文武,陈慧琴,郭会光. Mn18Cr18N奥氏体不锈钢的压缩拉伸连续加载变形行为*[J]. 金属学报, 2016, 52(8): 956-964.
[6] 郭巍巍,齐成军,李小武. 共轭和临界双滑移取向Cu单晶体疲劳位错结构的热稳定性研究*[J]. 金属学报, 2016, 52(6): 761-768.
[7] 郭跃岭, 韩恩厚, 王俭秋. 锻造和热处理对316LN不锈钢在高温碱性溶液中应力腐蚀行为的影响*[J]. 金属学报, 2015, 51(6): 659-667.
[8] 王效光,李嘉荣,喻健,刘世忠,史振学,岳晓岱. DD9单晶高温合金拉伸性能各向异性[J]. 金属学报, 2015, 51(10): 1253-1260.
[9] 董旭光,付俊伟,杨院生. Al和Zn对铸造Mg-5Sn合金微观组织和力学性能的影响[J]. 金属学报, 2013, 49(5): 621-628.
[10] 李秀程, 谢振家, 王学林, 王学敏, 尚成嘉. 高强度低碳贝氏体钢拉伸断口分离现象及机理研究[J]. 金属学报, 2013, 49(2): 167-174.
[11] 郭巍巍,齐成军,李小武. 一个共面双滑移取向Cu单晶体疲劳位错结构的热稳定性研究[J]. 金属学报, 2013, 49(1): 107-114.
[12] 刘大海,于海平,李春峰. 5052铝合金板材磁脉冲动态拉伸塑性失稳分析[J]. 金属学报, 2012, 48(5): 519-525.
[13] 陈畅 汪明朴 王珊 贾延琳 左波 夏福中. Ta-7.5%W合金箔材冷轧过程中的位错结构演变[J]. 金属学报, 2011, 47(8): 984-989.
[14] 刘恩泽 郑志 佟健 宁礼奎 管秀荣. DZ468合金高周疲劳性能研究[J]. 金属学报, 2010, 46(6): 708-714.
[15] 张莹 张义文 张娜 刘明东 刘建涛. 粉末冶金高温合金FGH97的低周疲劳断裂特征[J]. 金属学报, 2010, 46(4): 444-450.