Please wait a minute...
金属学报  2012, Vol. 48 Issue (10): 1175-1185    DOI: 10.3724/SP.J.1037.2012.00236
  论文 本期目录 | 过刊浏览 |
800H合金动态再结晶行为研究
曹宇1,邸洪双1,张洁岑1,张敬奇1,马天军2
1.东北大学轧制技术及连轧自动化国家重点实验室, 沈阳 110819
2.宝山钢铁股份有限公司特钢事业部, 上海 200940
RESEARCH ON DYNAMIC RECRYSTALLIZATION BEHAVIOR OF INCOLOY 800H
CAO Yu1, DI Hongshuang1, ZHANG Jiecen1, ZHANG Jingqi1, MA Tianjun2
1.State Key Laboratory of Rolling and Automation, Northeastern University, Shenyang 110819
2.Special Steel Business Unit, Baoshan Iron&Steel Co., Ltd., Shanghai 200940
全文: PDF(3458 KB)  
摘要: 

在MMS-300热模拟机上对800H合金进行了单道次压缩实验, 结合EBSD和TEM等技术, 研究了该合金在850-1100 ℃和0.01-10 s-1变形条件下的动态再结晶行为. 结果表明, 当变形温度低于950 ℃时, 析出了大量Cr23C6和Ti(C,N)析出相, 其对动态再结晶行为产生明显的抑制作用. 建立了2段温度区间内(850-950 ℃和950-1100 ℃)800H合金的热变形本构方程; 采用lnθ-ε曲线的三次多项式拟合求解拐点的方法, 较准确地预测了800H合金动态再结晶临界应力/峰值应力和临界应变/峰值应变的比值, 并建立了临界应力、临界应变与$Z$参数的关系;800H合金在热变形过程中动态再结晶形核机制主要包括应变诱导晶界迁移、晶粒碎化以及亚晶合并形核机制.

关键词 800H合金 动态再结晶 本构方程 临界应变 应变诱导晶界迁移    
Abstract

In order to optimize the hot working technology of Incoloy 800H, the dynamic recrystallization (DRX) behavior of Incoloy 800H at temperatures ranging from 850 ℃ to 1100 ℃ and strain rates from 0.01 s-1 to 10 s-1 was investigated by single–pass compression tests on MMS–300 thermo–mechanical simulator. The evolutions of microstructure and nucleation mechanisms of DRX were analyzed combined with the technique of EBSD and TEM. The results show that when the deformation temperature is below 950 ℃, the behavior of DRX is obviously restrained by precipitation of Cr23C6 and Ti(C,N). Therefore the hot deformation constitutive equations in two temperature intervals (from 850 ℃ to 950 ℃and from 950 ℃ to 1100 ℃) were established by regression analysis with the deformation activation energy of 465.394 kJ/mol and 427.360 kJ/mol respectively. The inflection points were determined by fitting a third order polynomial to the lnθ–ε curves, which makes the prediction for the ratios of critical stress to peak stress and critical strain to peak strain more accurately. Accordingly, the mathematical models of critical stress and critical strain vs Z parameter were deduced. The DRX nucleation mechanisms of Incoloy 800H during hot deformation mainly include strain induced grain boundary migration, grain fragmentation and subgrain coalescence.

Key wordsIncoloy 800H    dynamic recrystallization    constitutive equation    critical strain    strain induced grain boundary migration
收稿日期: 2012-04-27      出版日期: 2012-10-11
ZTFLH:  TG146.4  
基金资助:

国家重点基础研究发展计划资助项目2011CB606306-2

通讯作者: 邸洪双     E-mail: dhshuang@mail.neu.edu.cn
作者简介: 曹宇, 男, 1986年生, 博士生

引用本文:

曹宇 邸洪双 张洁岑 张敬奇 马天军. 800H合金动态再结晶行为研究[J]. 金属学报, 2012, 48(10): 1175-1185.
CAO Yu DI Hongshuang ZHANG Jiecen ZHANG Jingqi MA Tianjun. RESEARCH ON DYNAMIC RECRYSTALLIZATION BEHAVIOR OF INCOLOY 800H. Acta Metall Sin, 2012, 48(10): 1175-1185.

链接本文:

http://www.ams.org.cn/CN/10.3724/SP.J.1037.2012.00236      或      http://www.ams.org.cn/CN/Y2012/V48/I10/1175

[1] Tan L, Rakotojaona L, Allen T R, Nanstad R K, Busby J T. Mater Sci Eng, 2011; A528: 2755
[2] Br¨unger E, Wang X, Gottstein G. Scr Mater, 1998; 38: 1843
[3] Wang X, Br¨unger E, Gottstein G. Mater Sci Eng, 2000; A290: 180
[4] Wang X, Br¨unger E, Gottstein G. Scr Mater, 2002; 46: 875
[5] Gottstein G, Frommert M, Goerdeler M, Sch¨afer N. Mater Sci Eng, 2004; A387-389: 604
[6] Abd El-Azim M E. J Nucl Mater, 1996; 231: 146
[7] Frommert M, Gottstein G. Mater Sci Eng, 2009; A506: 101
[8] Sun C Y, Liu J R, Li R, Zhang Q D. Acta Metall Sin, 2011; 47: 191(孙朝阳, 刘金榕, 李瑞, 张清东. 金属学报, 2011; 47: 191)
[9] McQueen H J, Ryan N D. Mater Sci Eng, 2002; A322: 43
[10] Venugopal S, Mannan S L, Rodriguez P. J Mater Sci, 2004; 39: 5557
[11] Naderi M, Durrenberger L, Bleck W. Mater Sci Eng, 2008; A478: 130
[12] McQueen H J. Mater Sci Eng, 2004; A387: 203
[13] Spigarelli S, Evangelista E, McQueen H J. Scr Mater, 2003; 49: 179
[14] Chen L Q, Zhao Y, Xu X Q, Liu X H. Acta Metall Sin, 2010; 46: 1219(陈礼清, 赵阳, 徐香秋, 刘相华. 金属学报, 2010; 46: 1219)
[15] Momeni A, Dehghani K, Keshmiri H, Ebrahimi G R. Mater Sci Eng, 2010; A527: 1607
[16] Zhang M J, Li F G, Wang S Y, Liu C Y. Mater Sci Eng, 2010; A527: 6778
[17] Cao Y, Di H S, Ma T J, Zhang J Q. J Northeastern Univ (Nat Sci Ed), 2012; 33: 215(曹宇, 邸洪双, 马天军, 张敬奇. 东北大学学报(自然科学版), 2012; 33: 215)
[18] Poliak E I, Jonas J J. Acta Mater, 1996; 44: 127
[19] Ryan N D, McQueen H J. Can Metall Q, 1990; 29: 150
[20] Barnett M R, Kelly G L, Hodgson P D. Scr Mater, 2000; 43: 366
[21] Gottstein G, Frommert M, Goerdeler M. Mater Sci Eng, 2004; A387-389: 604
[22] Poliak E I, Jonas J J. ISIJ Int, 2003; 43: 684
[23] Najafizadeh A, Jonas J J. ISIJ Int, 2006; 46: 1679
[24] Mirzadeh H, Najafizadeh A. Mater Des, 2010; 31: 1174
[25] McQueen H J, Yue S, Ryan N D, Fry E. J Mater Process Technol, 1995; 53: 295
[26] Hansen N, Huang X. Acta Metall, 1998; 46: 1827
[27] Yu J W, Liu X F, Xie J X. Acta Metall Sin, 2011; 47: 486(余均武, 刘雪峰, 谢建新. 金属学报, 2011; 47: 486)
[28] Winning M. Scr Mater, 2008; 58: 86
[1] 王菲,王恩刚,贾鹏,王韬,邓安元. 电磁连铸对Incoloy800H合金铸坯内TiN分布和内裂纹的影响[J]. 金属学报, 2017, 53(1): 97-106.
[2] 蔡贇,孙朝阳,万李,阳代军,周庆军,苏泽兴. AZ80镁合金动态再结晶软化行为研究*[J]. 金属学报, 2016, 52(9): 1123-1132.
[3] 高博,王磊,梁涛沙,刘杨,宋秀,曲敬龙. 定向凝固U720Li合金的高温塑性变形行为*[J]. 金属学报, 2016, 52(4): 437-444.
[4] 袁晓云, 陈礼清. 一种高锰奥氏体TWIP钢的高温热变形与再结晶行为*[J]. 金属学报, 2015, 51(6): 651-658.
[5] 李俊儒, 龚臣, 陈列, 佐辉, 刘雅政. 10Cr12Ni3Mo2VN超超临界机组用叶片钢的热变形行为[J]. 金属学报, 2014, 50(9): 1063-1070.
[6] 鲁世强, 王克鲁, 李鑫, 刘诗彪. 一种模拟和预测金属锻造过程动态再结晶的新方法[J]. 金属学报, 2014, 50(9): 1128-1136.
[7] 付明杰, 韩秀全, 吴为, 张建伟. Ti-23Al-17Nb合金板材超塑性研究*[J]. 金属学报, 2014, 50(8): 955-961.
[8] 张飞, 沈健, 闫晓东, 孙建林, 蒋呐, 周华. 2099合金热变形过程中的动态软化机制*[J]. 金属学报, 2014, 50(6): 691-699.
[9] 韩忠, 姚斌, 卢柯. 纳米结构Cu中动态再结晶主导的磨损机制*[J]. 金属学报, 2014, 50(2): 238-244.
[10] 曹宇,邸洪双,张敬奇,马天军,张洁岑. 800H合金热变形行为及热加工性能研究[J]. 金属学报, 2013, 49(7): 811-821.
[11] 孔凡涛,崔宁,陈玉勇,熊宁宁. Ti-43Al-9V-Y合金的高温变形行为研究[J]. 金属学报, 2013, 49(11): 1363-1368.
[12] 温道胜,宗影影,徐文臣,杨单媚,单德彬. 0.037%H对铸态Ti-45Al-5Nb-0.8Mo-0.3Y合金高温变形行为的影响[J]. 金属学报, 2013, 49(11): 1428-1432.
[13] 韩国明,崔传勇,谷月峰,胡壮麒,孙晓峰. 一种镍基高温合金PLC效应的温度依赖性研究[J]. 金属学报, 2013, 49(10): 1243-1247.
[14] 余晖 KIM Youngmin 于化顺 YOU Bongsun 闵光辉. Mg-Zn-Zr-Ce合金高温变形行为与热加工性能研究[J]. 金属学报, 2012, 48(9): 1123-1131.
[15] 田宇兴 李述军 郝玉琳 杨锐. Ti2448合金高温变形行为及组织演变机制的转变[J]. 金属学报, 2012, 48(7): 837-844.